2004 Saturn Ion-2 Base Sedan 4-door 2.2l on 2040-cars

Auto blog

GM recalling another 2.7 million vehicles in five separate campaigns

The recalls keep rolling in from General Motors, evidently keen to avoid repeating the mistakes of the ignition-switch debacle and clean house. This time they're all coming at once, with five separate recalls announced together covering approximately 2.7 million vehicles.
The largest of the five actions involves over 2.4 million units of the previous-generation Chevrolet Malibu and Malibu Maxx, Pontiac G6 and Saturn Aura in order to fix brake light wiring harness, which have been found to be susceptible to corrosion. The recall is separate from the 56k Aura sedans which GM recently recalled over faulty shift cables, not to mention the previous massive recall of 1.3 million vehicles - some of them the same models - but appears to have resulted from the National Highway Traffic Safety Administration investigation that started with the G6 almost a year ago.
The second-largest campaign involves the 2014 Chevy Malibu, specifically those fitted with GM's 2.5-liter engine and stop/start system, approximately 140,000 examples of which has been found to have problematic brakes. The issue does not appear to be connected to the recall of 8k Malibu and Buick LaCrosse sedans (also involving brake woes) which we reported upon last week. Four crashes have been reported in such models, but GM admits it's not yet clear if the problem was a contributing factor in the accidents.

GM expands ignition switch recall to over 1.3 million cars amid climbing death toll

588,000 Saturn Sky, Saturn Ion, Pontiac Solstice and Chevy HHR models join the 778,000 cars already being recalled.
General Motors has announced a massive expansion of a 778,000-unit recall we told you about two weeks ago, doubling not only the total number of cars affected but expanding the recall beyond Chevrolet Cobalt and Pontiac G5 models previously mentioned. The recall originally centered around ignition switches that could slip out of the "run" position if jostled or if any weight was applied to the key in the cylinder.

303 Deaths Tied To Airbag Non-Deployment In 2 General Motors' Cars

At least 303 motorists died in car accidents after their airbags didn't deploy in now-recalled General Motors vehicles, according to a study released late last night. The Center for Auto Safety, a non-profit automotive watchdog, reviewed data from the Fatality Analysis Reporting System, and counted deaths involving the Chevrolet Cobalt and Saturn Ion, two vehicles at the heart of several ongoing investigations, to reach its conclusion. If the airbag non-deployments were the result of a faulty ignition switch that inadvertently turns them off, the death toll would be the largest in automotive history attributed to a single defect, surpassing the 250 deaths investigators linked to defective Firestone Tires more than a decade ago. The rising death toll would further amplify questions about why GM and federal safety regulators at the National Highway Traffic Safety Administration didn't act sooner to correct the problem. Safety advocates have said both GM and NHTSA failed to act in a timely fashion to alert motorists of the dangers posed by the dangerous defect, of which documents GM had knowledge of as early as 2001 and NHTSA knew about in 2007. "The question today for NHTSA is how so many ... death reports without an airbag deployment and so many FARS deaths without an airbag deployment failed to trigger an investigation," wrote Clarence Ditlow, the executive director of the Center for Auto Safety. "... For the people who died or were seriously injured in crashes, the answer comes too late." GM has acknowledged 13 deaths related to the problem, and says the number cited by the Center for Auto Safety study is "speculation." The review of FARS data, conducted by Friedman Research at the request of the Center for Auto Safety, looked at fatal cases in which airbags did not deploy but did not analyze the causes of the crashes. FARS information is raw data submitted to a national database by state and local authorities when fatal accidents occur. Last month, GM recalled 1.37 million cars in the U.S. because a faulty ignition switch had been inadvertently moving from the "run" position to the "accessory" position, turning off engines and systems that provide power to airbags. "Shame is not a strong enough word," said Lou Lombardo, the founder of Care for Crash Victims, another safety-minded nonprofit that advocates for accident victims. The results of the CAS study were first reported by the New York Times.