1965 Pontiac Bonneville Base 6.4l on 2040-cars

Auto blog

GM recalls 61k more vehicles in three campaigns

Following a stop-delivery order for its new midsize trucks and a rash of recent recalls, General Motors is issuing three more campaigns covering 60,575 vehicles in North America with 57,182 of them in the US. As of October 1, the automaker has issued a total of 74 recalls (see the ridiculously long chart to the right) this year covering 26,495,070 units in the US.
The largest campaign covers 46,873 examples in the US of the 2008-2009 Pontiac G8 and 2011-2013 Chevrolet Caprice Police Patrol Vehicle imported from Australia. It's possible for the driver's knee to hit the key and make it move from the "Run" to "ACC" position while driving. GM says its Holden division is developing a fixed-blade key that's supposed to fix the problem by only allowing it to rotate toward the "On" position. There has been one crash caused by this fault but no injuries or fatalities.
The second recall is for 10,005 units of the 2004-2007 Cadillac CTS-V and 2006-2007 Cadillac STS-V because "the fuel pump module electrical terminal may overheat." This can cause a flange to melt and allow the pump to leak fuel. GM specifies that the remedy for the CTS-V is replacing the fuel module and fuel tank jumper harness, but it doesn't specify how the STS-V is being repaired.

NHTSA investigating 550k Pontiac G6 models, 320k Honda Odysseys

According to two separate reports in The Detroit News, the National Highway Traffic Safety Administration is launching investigations into 550,000 Pontiac G6 (pictured above) and 320,000 Honda Odyssey (pictured right) models. The G6 models are all from the 2005 to 2007 model years, while the Odyssey minivans are from the 2003 and 2004 model years. The two NHTSA probes are not related.
In the case of the G6, this is an upgrade to an original investigation that started in February after NHTSA received "hundreds of reports" that the brake lights on these cars may malfunction. According to The Detroit News, the lights may come on when the brake pedal is not depressed, and likewise, the brake lights may not illuminate when the pedal has been pushed. General Motors was able to provide NHTSA with a significant number of warranty claims, including 1,100 reports that could potentially relate to this problem, one of which indicates a vehicle crash.
For Honda, the NHTSA probe concerns airbags that may deploy unexpectedly. The government agency received six complaints from 2003-04 Odyssey owners saying that the front airbags suddenly went off without a crash. The Detroit News reports that three of the six owners sustained injuries from these incidents. Additionally, NHTSA has received 41 complaints from owners saying the vehicle's airbag warning light had illuminated.

GM knew about fatal Chevy ignition problem decade before recall

Well, this is not good for General Motors. Following a report last week that GM was recalling 778,000 Chevrolet Cobalt and Pontiac G5 compacts over concerns that the ignition could switch out of the "run" position without warning, USA Today reports that the Detroit-based behemoth knew about the issue, which affected 2005 to 2007 Cobalts (the Cobalt shown above and in the gallery is from 2010) and 2007 Pontiac G5s, all the way back in 2004.
The information comes from a deposition in a civil lawsuit against GM, obtained by USA Today, which claims that a GM engineer experienced the issue while the then-new model was undergoing testing. The issue was "solved" when a technical service bulletin was issued in 2005, informing dealers to install a snap-on key cover on the cars of customers who complained about the issue. According to the Cobalt's program engineering manager, Gary Altman, the cover was an "improvement, it was not a fix to the issue."
The case where the depositions were made was from 2010, and involved Brooke Melton, a 29-year-old pediatric nurse in Georgia who was killed on her birthday. At the time, police claimed she was going too fast on a wet, rural road, although it later came out through the black box that her car's ignition had come out of the "run" position at least three seconds before the accident (the max amount of time a black box records before a wreck), disabling her airbags, power steering and anti-lock brakes. According to USA Today, police said Melton was "traveling too fast for the roadway conditions," although it's impossible to know if she'd have been in the wreck, which injured the occupants of another vehicle, had her 2005 Chevy not shut off. GM settled the Melton family's case, although the details remain confidential.