1993 Mercury Capri Base Convertible 2-door 1.6l on 2040-cars

Auto blog

NHTSA and Ford investigating steering issues in Crown Vic, Grand Marquis and Marauder

There may be more steering woes for the Ford Crown Victoria. The National Highway Traffic Safety Administration has opened a preliminary evaluation into the Crown Vic and Mercury Grand Marquis from the 2004 to 2007 model years and the Mercury Marauder for the 2004 and 2005 model years because the steering shaft can jam. The issue could potentially affect an estimated 500,000 vehicles.
According to the regulator, there is a possibility that the driver's side heat shield for the exhaust manifold can rust, dislodge, and then wedge into the steering shaft. If this occurs, it leads to a situation where the driver can no longer control the car.
NHTSA has received five complaints of this happening, including one alleged case with an injury. In that situation, the car was driving onto the highway, lost control and rolled over. One occupant was hurt in the accident.

NHTSA investigating 500k Ford and Mercury cars for lighting failures

The Ford Crown Victoria and Mercury Grand Marquis might be long gone as new models in showrooms, but the National Highway Traffic Safety Administration might check them out yet again for a potential problem. At the urging of North Carolina Consumers Council, the agency may open another investigation into the front lighting control module on vehicles from the 2003-2005 model years, and NHTSA estimates the issue could affect 517,945 vehicles. If the module stops working, it can cause a complete failure of all forward lighting, including the headlights. NHTSA previously investigated the issue in 2008 and 2009 but found no need for a recall, according to Bloomberg. Ford also extended the warranty on the part to 15 years or 250,000 miles. To prompt this new request, the North Carolina Consumers Council received a letter from a woman experiencing the module's failure. Upon further investigation, the council found 604 complaints of this problem on NHTSA's website, including seven crashes. Furthermore, the group has alleged that dealers told customers that the parts to perform the replacement weren't available, despite the extended warranty. According to the government agency, "A defect petition has been opened to evaluate the issue and make a grant or deny decision." Ford spokesperson Kelli Felker tells Autoblog via email, "We will cooperate with NHTSA, as we always do." You can read the council's complete letter to the Feds in PDF format, here. INVESTIGATION Subject : Loss of headlamp/exterior lighting Date Investigation Opened: APR 01, 2015 Date Investigation Closed: Open NHTSA Action Number: DP15002 Component(s): EXTERIOR LIGHTING All Products Associated with this Investigation Vehicle Make Model Model Year(s) FORD CROWN VICTORIA 2003-2005 MERCURY GRAND MARQUIS 2003-2005 Details Manufacturer: Ford Motor Company SUMMARY: The Office of Defects Investigation (ODI) has received a petition from the North Carolina Consumers Council, Inc. requesting a defect investigation of an alleged defect condition resulting in headlight and/or exterior lighting failure on 2003-2005 Ford Crown Victoria and Mercury Grand Marquis vehicles. The petition letter is attached for review. The petitioner alleges a defect in the lighting control module that powers the headlights which can result in the loss of vehicle headlights and/or all exterior lighting while driving. ODI has previously investigated this issue under PE08-066 which was closed without a defect finding.

Ford Announces Free Brake-Pad Offer If Customers Stop By Dealers

These days, when you buy a new car, it's not unreasonable to expect a certain period of free maintenance to come along as well. Sometimes this is through the life of the warranty, in other cases a little less. But Ford Motor Company is going beyond those deals for at least one part of its cars. As of now, if you buy a set of Motorcraft brake pads for a Ford, Lincoln or Mercury model, you get free replacements for as long as you own the vehicle. The offer is good at Ford or Lincoln dealers and Quick Lane Tire & Auto Centers. "We will replace the pads for as long as you own the vehicle," said Elizabeth Weigandt to Autoblog. She did clarify that the Motorcraft pads are generally for models from the '90s or newer. Also, to take advantage of this program, a person must return to the same dealer each time to get the free parts. Of course, Ford isn't just handing out brake pads to anyone who walks by; there are certain stipulations. First, the components have to be worn down to less than three millimeters to be eligible, and the buyer still has to pay for the labor to install them. If the model is used as a fleet vehicle for commercial purposes like as a taxi or limousine, this offer also doesn't apply; the same thing for racecars. On the plus side, if you recently bought a set of pads from one of the participating locations, you're still in luck. The deal covers parts purchased as of July 1. "This program reflects our commitment to providing customers with an excellent ownership experience regardless of the age of their vehicle," said Frederiek Toney, President of Ford Customer Service, in the company's announcement of the offer. Scroll down to read the all the details.