2006 Unlimited Rubicon Supercharged 4l I6 12v Manual 4wd Suv Cd on 2040-cars

Auto blog

NHTSA closes probes on Jeep Grand Cherokee, Ford Freestar and Mercury Monterey

The Detroit News reports the National Highway Traffic Safety Administration has officially closed its investigations into 2012 Jeep Grand Cherokee, 2004-2005 Ford Freestar and Mercury Monterey models. The separate probes found no issues that pose safety concerns. NHTSA began investigating certain Grand Cherokee SUVs over complaints that power steering hoses could detach during operation, thereby increasing the risk of a vehicle fire. Of the 24 reports of failure, none alleged smoke or fire in the engine bay, and Chrysler has since modified the power steering cooler assembly to reduce the likelihood of the failure.
Meanwhile, certain Ford Freestar and Mercury Monterey vehicles garnered a government probe after receiving complaints that the models were equipped with faulty scissor jacks. The agency had received six reports of the jacks failing or causing injuries, including one incident that resulted in a fatality. But NHTSA says the jack failure rate is similar to those found in other vehicles. In those six cases, the government agency found the jacks were being used for something other than changing a tire, and investigators could not determine whether the emergency brake was set or the rear tires were properly chocked.

164K Jeep Cherokees recalled to protect liftgate from moisture

FCA is recalling 164,003 examples of the 2014 and 2015 Jeep Cherokee because moisture can damage the power liftgate controls on models that are equipped with that feature. Regionally, this includes 99,436 of them in the US, 13,195 in Canada, 2,406 in Mexico, and 48,966 outside of NAFTA. The problem came to light after the automaker started investigating a fire in one of the SUVs. There were no injuries, though. According to FCA US' research, the power hatch's control module potentially can be exposed to water. This can cause a short circuit and possibly a fire, as in this case. Until the issue is repaired, the company is advising owners to keep the cargo area dry on Cherokees equipped with this feature. To fix things, dealers will install a shield around the controls to protect them from moisture and will replace any modules showing exposure to water. Statement: Water-Shield Installation June 24, 2015 , Auburn Hills, Mich. - FCA US LLC is voluntarily recalling an estimated 99,436 SUVs in the U.S. to install shields that protect their power liftgate control modules, and related components, from moisture. FCA US LLC began an investigation after learning of a reported vehicle fire. The probe revealed power liftgate control modules in certain SUVs may be inadvertently exposed to water. This may cause a short-circuit, creating a fire hazard. However, the Company is unaware of any related injuries or accidents. The campaign affects model year 2014 and 2015 Jeep Cherokee SUVs, but is limited to vehicles equipped with power liftgates. An estimated 13,195 customers are affected in Canada, along with an estimated 2,406 customers in Mexico and 48,966 outside the NAFTA region. The estimated total recall population is 164,003. All affected customers will be advised when they may schedule service. If the modules show signs of water exposure, they will be replaced. All recall-related work will be performed free of charge. In the interim, the cargo areas of 2014-15 Cherokees equipped with power liftgates should be monitored and kept dry. Customers with questions may call the FCA US Customer Information Center at 1-800-853-1403.

Jeep will build old Wranglers next to new ones in Toledo

Jeep made a lot of people happy when it confirmed that the next-generation Wrangler would continue to be built in Toledo, OH. Now, news is breaking about the lengths the automaker will go to in updating its northern Ohio factory. There's good news for Jeep dealers (more Wranglers to sell!), Jeep fans (more JKs to buy!), and Jeep itself (more money to be made!). According to a report from Automotive News, capacity at the factory will be increased to 350,000 units per year. That's around a 50 percent increase over what the Toledo complex can currently manage and is, according to Jeep boss Mike Manley, part of a move to keep production "at the right place" so "supply [stays] just behind demand." The other big news revealed by the AN report focuses on the future of the current Wrangler. Yes, the current JK has a future. It'll continue to be built at the Toledo factory up to six months after it successor arrives in showrooms, a move that's partially down to the way Jeep is shuffling production about. Toledo currently builds the Cherokee on a unibody production line – it'll continue to do so until March of 2017, when production will move to Belvidere, IL. The unibody line in Toledo will then be converted for body-on-frame production, which should take about six months. But during that time, the current JK (likely rebadged as a "Wrangler Classic") will continue to be built alongside another line of next-generation Wranglers, keeping dealers supplied with the today's Wrangler through March of 2018. The two Wranglers will overlap for about six months. This is all very good news if you've been waiting to pull the trigger on today's Wrangler. But move quickly – the clock is officially ticking. Related Video: News Source: Automotive News - sub. req.Image Credit: Bill Pugliano/Getty Images Plants/Manufacturing Chrysler Fiat Jeep FCA toledo Mike Manley