1995 Jeep Yj Wrangler, Rust Free, Lifted, Zombie Response Unit on 2040-cars

Auto blog

NHTSA upgrading Jeep Grand Cherokee, Dodge Durango headliner fire probe

The National Highway Traffic Safety Administration investigation into headliner fires experienced by a small number of Jeep Grand Cherokee and Dodge Durango owners has been upgraded to an engineering analysis, the step before the initiation of a recall. In August last year the investigation began with 146,000 Grand Cherokees from 2012 after three complaints were received, but a report on Edmunds says it has been expanded to include 593,299 vehicles covering the 2011-2013 model years for the Jeep and the Dodge Durango, which uses the same headliner assembly, because of possibly 52 incidents of fire.
In some of those incidents drivers have reported a burning odor, smoke or open flames that were contained to the headliner or migrated to another area of the passenger compartment. The culprit has apparently been found: NHTSA blaming an electrical short in the sun visor vanity light wiring, which is routed under the headliner and held in place by three screws. Chrysler began its own probe into the issue when it was first reported and is still looking into the situation while, "fully supporting the National Highway Traffic Safety Administration's investigation."

FCA recalls 570,000 SUVs from Jeep and Dodge over fire woes

Fiat Chrysler US has issued two recalls covering a total of about 570,000 Jeep and Dodge models. The first concerns vanity mirror wiring in the Jeep Grand Cherokee from the 2011 and 2012 model years, and in Dodge Durango units built before September 12, 2012. The automaker recalled almost 900,000 units last year to repair the issue, then faced more issues this year when the fires continued in repaired vehicles. This new recall seeks to resolve the issue, FCA saying that the post-recall fires happened in a tiny percentage of vehicles equipped with a specific wiring package. This recall is for 352,831 total units in the US, another 26,478 in Canada, 13,037 in Mexico, and 84,330 internationally. No injuries or deaths have been reported. FCA says it will inform customers as to when they can schedule a service visit to remedy the issue. The second recall takes aim at 60,107 examples of the Jeep Compass and Patriot from the 2015 model year in the US, plus 5,755 in Canada, 3,351 in Mexico, and 23,995 in other markets. Those models could suffer from an out-of-position clamp on the power steering fluid line. The error could allow fluid to leak, increasing the risk of a fire if the fluid ends up on a hot surface. In the case of a complete loss of fluid, drivers will need to use a lot more effort to steer. The automaker reports no injuries or accidents, and will advise customers when to head to the dealer for service. Related Video: Jeep Grand Cherokee and Dodge DurangoStatement: Vanity-Mirror WiringDecember 24, 2015 , Auburn Hills, Mich. - FCA US LLC is recalling an estimated 352,831 SUVs in the U.S. to help ensure vanity-mirror wiring may be serviced more consistently.Overheating conditions were reported among a small percentage of vehicles (<0.02%) serviced in connection with a related recall, conducted previously.** An FCA US LLC investigation discovered the service procedure, if not followed precisely, may leave vehicles susceptible to a short-circuit, creating a potential fire hazard.The Company is unaware of any related injuries or accidents. Post-service overheating conditions were observed only in vehicles equipped with a certain wiring package. These vehicles were produced before Sept. 2, 2012.Affected are model-year 2011-2012 Jeep Grand Cherokee and Dodge Durango SUVs produced before Sept. 2, 2012. Wiring in the headliners of these vehicles will be secured with a new adhesive.

Video charts evolution of Jeep from military vehicle to SUV powerhouse

Here's a fun new video from our car-obsessed friends at Donut Media. It shows the evolution of the iconic Jeep from its World War II roots to the forthcoming 2019 Scrambler pickup in a little over two minutes. Using illustrations and audio of Jeep engines and broadcast advertising spots, it's a fascinating look at the common traits that have persisted over more than 75 years and changing consumer preferences. Three companies originally responded to the U.S. Army's request in 1940 for proposals to make a quarter-ton "light reconnaissance vehicle" tailored to its specs — Bantam, Ford and Willys. The video starts by showing all three early contenders — the Bantam Reconnaissance Car, Ford Pygmy and Willys MB, which was based on the Willys-Overland "Quad" prototype, named for the 4x4 system it utilized. Willys eventually won the contract in 1941 to build 16,000 revised MB models for American and Allied forces. Willys would trademark the Jeep name in 1945 with its CJ-2A, a Civilian Jeep geared toward farmers. As the video shows, Jeep really started to diversify its body styles and colors in the 1970s and '80s under the ownership of American Motors Corp., which purchased the money-losing Jeep brand in 1970 from Kaiser-Jeep, which itself had acquired the brand from Willys in 1953. The '70s brought models like the CJ-5 Renegade and CJ-5 Laredo, and the video includes updates including the second-generation Wrangler Unlimited in 2004 and the Wrangler-based Scrambler pickup. Chrysler purchased Jeep from American Motors in 1987, shortly after the debut of the Jeep Wrangler, and has managed to hold onto the brand and ride it to success despite its own bumpy ownership trials and tribulations since then. Despite the many owners over time, Jeep has maintained its headquarters all along in Toledo, Ohio.