1982 Jeep Cj 8 Scrambler Resto Mod! Must See! on 2040-cars

Auto blog

FCA recalls 570,000 SUVs from Jeep and Dodge over fire woes

Fiat Chrysler US has issued two recalls covering a total of about 570,000 Jeep and Dodge models. The first concerns vanity mirror wiring in the Jeep Grand Cherokee from the 2011 and 2012 model years, and in Dodge Durango units built before September 12, 2012. The automaker recalled almost 900,000 units last year to repair the issue, then faced more issues this year when the fires continued in repaired vehicles. This new recall seeks to resolve the issue, FCA saying that the post-recall fires happened in a tiny percentage of vehicles equipped with a specific wiring package. This recall is for 352,831 total units in the US, another 26,478 in Canada, 13,037 in Mexico, and 84,330 internationally. No injuries or deaths have been reported. FCA says it will inform customers as to when they can schedule a service visit to remedy the issue. The second recall takes aim at 60,107 examples of the Jeep Compass and Patriot from the 2015 model year in the US, plus 5,755 in Canada, 3,351 in Mexico, and 23,995 in other markets. Those models could suffer from an out-of-position clamp on the power steering fluid line. The error could allow fluid to leak, increasing the risk of a fire if the fluid ends up on a hot surface. In the case of a complete loss of fluid, drivers will need to use a lot more effort to steer. The automaker reports no injuries or accidents, and will advise customers when to head to the dealer for service. Related Video: Jeep Grand Cherokee and Dodge DurangoStatement: Vanity-Mirror WiringDecember 24, 2015 , Auburn Hills, Mich. - FCA US LLC is recalling an estimated 352,831 SUVs in the U.S. to help ensure vanity-mirror wiring may be serviced more consistently.Overheating conditions were reported among a small percentage of vehicles (<0.02%) serviced in connection with a related recall, conducted previously.** An FCA US LLC investigation discovered the service procedure, if not followed precisely, may leave vehicles susceptible to a short-circuit, creating a potential fire hazard.The Company is unaware of any related injuries or accidents. Post-service overheating conditions were observed only in vehicles equipped with a certain wiring package. These vehicles were produced before Sept. 2, 2012.Affected are model-year 2011-2012 Jeep Grand Cherokee and Dodge Durango SUVs produced before Sept. 2, 2012. Wiring in the headliners of these vehicles will be secured with a new adhesive.

FCA recalls 894k total vehicles worldwide in two campaigns

FCA is recalling a total of 893,698 vehicles worldwide in two campaigns to fix problems with inadvertent airbag deployment, failure of the anti-lock brakes, and stability control systems in the Jeep Grand Cherokee, Liberty, Dodge Journey, and Fiat Freemont. 559,703 of these vehicles are in the US. The larger recall affects 284,089 examples of the 2003 Jeep Liberty and 2004 Jeep Grand Cherokee, and there are also 13,411 of them in Canada, 6,277 in Mexico, and 48,212 outside the NAFTA region. Because of "electrical noise beyond the tolerance of the airbag electronic control module", part of that component can fail, according to the National Highway Traffic Safety Administration. This can cause the front and side airbags to deploy and the seatbelt pre-tensioners to activate inadvertently. FCA US has seven reports of alleged injuries from this problem. To fix the situation, the Jeeps need their Occupant Restraint Control modules replaced, as well as the front- and side-impact sensors. According to the NHTSA, the replacement parts won't be available until early 2016. Still, FCA US will advise owners about the problem in a letter by the end of December and will send a second notification when the components are ready. The second campaign affects 275,614 examples of the 2012-2015 Dodge Journey in the US; plus 78,148 of them in Canada, 36,471 in Mexico, and 151,476 left-hand drive units outside of NAFTA where it's sold as the Fiat Freemont. On these vehicles, water intrusion can disable the anti-lock brakes and electronic stability control, although a warning light often illuminates when this issue occurs, and the problem doesn't affect regular braking. There are also no reports of injuries or accidents. To fix the issue, dealers will seal the ABS wiring harness and will replace any already affected components as necessary, like the ABS module or the headlamp and dashboard wiring harness. Statement: Occupant Restraint Control Modules October 30, 2015 , Auburn Hills, Mich. - FCA US LLC is voluntarily recalling an estimated 284,089 older-model SUVs in the U.S. to replace their Occupant Restraint Control (ORC) modules and front and/or side-impact sensors, as required. Within this vehicle population, FCA US became aware of seven injuries caused by inadvertent air-bag deployments and advised NHTSA accordingly. The affected vehicles are not equipped with Takata Corp. air-bags. The Company is unaware of any related accidents.

Jeep Wrangler production in Toledo to nearly double by 2018

The Jeep Wrangler's future in Toledo, OH, is officially secure. FCA US announced plans on Thursday to spend $1.05 billion to retool the Wrangler factory and another site in Illinois to build Jeeps. The investment could add up to 1,000 jobs, and, according to The Detroit Free Press, allow Jeep to build as many as 450,000 Wrangler models in Toledo. FCA is investing $700 million to make over the Toledo North factory to build the next-generation Wrangler – a vehicle that's hotly anticipated by enthusiasts. FCA said this will add about 700 new jobs. The Wrangler factory is part of a multi-site complex in Ohio, and FCA said an announcement about the South factory will come later. Nearly two years ago, FCA chief executive Sergio Marchionne touched off a firestorm by suggesting the Wrangler could leave Toledo, though plans to keep the iconic Jeep there quickly proceeded. Automotive News reports the new Wrangler will use some aluminum elements, run a turbo four-cylinder engine, and offer a diesel variant. Designers will also pay increased attention to aerodynamics, though maintain the Wrangler's familiar appearance. Additionally, FCA reportedly plans to build a Wrangler pickup in Toledo. That 450,000-vehicle threshold could potentially break down into 350,000 traditional Wrangler models, along with another 100,000 Wrangler-based pickup trucks. When the current Toledo plant was opened in 2005, Chrysler said its capacity was about 150,000 vehicles per year. Since then, that figure has increased to about 240,000 Wranglers yearly, and Jeep has no problem selling that many. FCA's factory in Belvidere, IL, gets $350 million for upgrades to produce the Jeep Cherokee, which moves there in 2017 from Toledo as part of a product shuffle. FCA builds the Dodge Dart and Jeep's Patriot and Compass in Belvidere. The automaker is killing the Dart and will replace the compact Jeeps with a single model next year. The moves are part of FCA's strategy to fortify the Jeep brand, which has posted healthy sales and enjoys a strong reputation around the world. Related Video: