1999 Isuzu Trooper S Sport Utility 4-door 3.5l on 2040-cars

Auto blog

16 things I learned about the Isuzu VehiCROSS

There are plenty of cars I remember existing, but actually know very little about due to the passage of time or just not particularly caring when they were new. Take the Isuzu VehiCROSS, which I fondly recall as this wackadoo off-roader from the late 1990s and early 2000s. But honestly, that's about it. So, since I've got a little extra time kicking about, I decided to fall into the rabbit hole labeled Isuzu VehiCROSS for an hour to see how much I could find out about this SUV (or "sport/utility" in 1999 parlance) that shared labeling with the watch I wore in 1999. Enjoy. 1) The VehiCROSS was not based on the Rodeo, as I always assumed, but rather the Trooper RS. Oh, so that bigger, boxier Isuzu they turned into an Acura? No, no, no. The RS was the two-door Trooper, and specifically the second-generation two-door Trooper, which I just discovered was a thing. And what a gawky, dorky, that-has-to-be-Photoshopped thing it was. Apparently, the Trooper RS was sold in the United States from 1993 to 1995, and in very small numbers. That is not surprising. 2) It was probably obvious, but the VehiCROSS was based on a concept car. Specifically, a concept car shown at the 1993 Tokyo auto show.  3) The quick turnaround from concept to its Japanese market introduction for 1997 was the result of some innovative manufacturing methods at the time (it arrived in the United States in 1999). According to the Motor Trend first drive, "There would be no time-consuming clinics, no 'courtroom drama' with the finance department, and to oversee the project, a 'Zip Team' consisting of 15-20 members was given the task of developing the vehicle in about half the normal time." Among its accomplishments, the team came up with a way to more quickly and cheaply produce the VehiCROSS' unique body pieces. Again according to Motor Trend, Isuzu used carbon stamping dies inside of the conventional cast iron dies. Though the carbon could be used far fewer times and result in a reduced overall capacity, they cost one-third to one-half as much and could be made in about six weeks – the cast iron ones would take four months and run about $1.5 million in 1990s dollars. Isuzu estimated they'd only be able to produce 2,400 VehiCROSSes per year until the carbon dies wore out. Then that would be it. According to sales data on Wikipedia, Isuzu managed to sell 2,005 in the U.S. alone in year 1 and 4,153 in total. In Japan, there were 1,805 sold in total.

GM SUV window switch recall urges owners to park vehicles outside

It's not unusual for there to be a lag between an automaker announcing a recall and the official documentation showing up on the National Highway Traffic Safety Administration website. So it's no surprise that a recent GM campaign took about a month to appear in its official capacity. However, there appears to be some big differences between the two reports with potential safety implications.
In late June, GM announced that it needed to recall 181,984 examples of the Chevrolet Trailblazer, Buick Rainier, GMC Envoy, Isuzu Ascender and Saab 9-7x from the 2005-2007 model years, plus the 2006 Chevy Trailblazer EXT and 2006 GMC Envoy XL. The new documents paint a slightly different picture with 184,611 needing repaired and different model years listed.
The reason for the fix is still the same, though. It's possible for fluid to contact the master power window switch module in the driver's door, which can corrode the part. Eventually this could cause a short circuit, leaving the buttons inoperable and potentially leading to a fire. But the new NHTSA documents add an important note: "A fire could occur even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made."

GM recalls over 230,000 more Trailblazer-family SUVs over door electronics

Back in August, the National Highway Traffic Safety Administration announced a recall on the General Motors GMT360 SUVs (Buick Rainier, Chevrolet Trailblazer, GMC Envoy, Isuzu Ascender and Saab 9-7X) ranging from the 2005 to 2007 model years and the 2006 GMT370 SUVs (Chevrolet Trailblazer EXT and GMC Envoy XL) due to potential fires associated with the driver's door module. Initially limited to 250,000 units sold or registered in 20 Snow Belt states (and the District of Columbia), the recall has now been expanded to include an additional 193,000 of these SUVs in the US and, according to The Detroit News, 40,000 more sold outside the US, including Canada and Mexico.
Like the original recall, the issue is still a faulty driver's door module that can short out, which could lead to a fire. The Detroit News is reporting that, out of the 443,000 units being recalled, GM says that there were 58 fires that caused 11 minor injuries, and the expanded recall accounted for six fires and one injury. Despite the lower number of fires, the recall notice recommends that owners park their vehicles until the recall repairs has been performed.
On recalled units with functional modules, the repair consists of a protective coating being applied to the module, while vehicles with modules that are not working properly will have the driver's door module replaced. The official recall notice is posted below, and it includes contact information for customers of all five brands.