1997 Isuzu Trooper on 2040-cars

Auto blog

GM re-recalls 11k SUVs

General Motors is recalling a bunch of previously recalled SUVs because, well, they still aren't quite fixed. The latest repairs are necessary on 10,974 SUVs in North America, including 9,932 in only the US. Affected models include the 2006-2007 Buick Rainier, Chevrolet Trailblazer, and GMC Envoy; plus the 2006 Trailblazer EXT and Envoy XL. While not listed by NHTSA, a statement by GM to Autoblog says the 2006-2007 Saab 9-7X and Isuzu Ascender are also affected. In these SUVs, it's possible that liquid could get into the driver's door master power window switch module and cause a short circuit. This could potentially lead to a fire, and owners are urged to park the vehicles outside until repaired. GM has been trying to fix this issue for years. It started as an investigation into fires, and that led to a recall for about 250,000 vehicles in cold-weather states. A nationwide campaign came in 2013 for 193,000 of them in the US. Last year, the automaker decided to replace the whole module as a repair. However in a recent investigation of these recalls, GM discovered that this latest group of SUVs never received the new part. According to documents submitted to NHTSA (as a PDF), "Some dealers incorrectly used the labor code associated with module replacement when, instead of replacing the module, they only added a protective coating to the module." To fix things this time, the models finally get the correct component. Related Video: GM Statement General Motors is recalling 9,932 older midsize SUVs in the U.S. because they were mistakenly excluded from an earlier recall. Certain 2006 Chevrolet TrailBlazer EXT and GMC Envoy XL, and 2006-2007 TrailBlazer, Envoy, Buick Rainier, Saab 9-7X and Isuzu Ascender vehicles may continue to have a condition in which the printed circuit board inside the driver's door may corrode and short if exposed to certain fluids such as melted snow containing road salt. GM is aware of four fires but no crashes, injuries or fatalities associated with the expanded recall. The total number of vehicles being recalled, including Canada, Mexico and exports is 10.974. Customers are urged to park these vehicles outside until repairs have been made. GM reported this recall to the NHTSA on September 23.

GM SUV window switch recall urges owners to park vehicles outside

It's not unusual for there to be a lag between an automaker announcing a recall and the official documentation showing up on the National Highway Traffic Safety Administration website. So it's no surprise that a recent GM campaign took about a month to appear in its official capacity. However, there appears to be some big differences between the two reports with potential safety implications.
In late June, GM announced that it needed to recall 181,984 examples of the Chevrolet Trailblazer, Buick Rainier, GMC Envoy, Isuzu Ascender and Saab 9-7x from the 2005-2007 model years, plus the 2006 Chevy Trailblazer EXT and 2006 GMC Envoy XL. The new documents paint a slightly different picture with 184,611 needing repaired and different model years listed.
The reason for the fix is still the same, though. It's possible for fluid to contact the master power window switch module in the driver's door, which can corrode the part. Eventually this could cause a short circuit, leaving the buttons inoperable and potentially leading to a fire. But the new NHTSA documents add an important note: "A fire could occur even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made."

Junkyard Gem: 1994 Isuzu Rodeo 4WD

After a decade in which Isuzu-built Chevrolet LUV pickups, Isuzu-engined Chevrolet Chevettes and Isuzu Geminis with confusing "Opel by Isuzu" or "Buick/Opel Isuzu" badges, Isuzu finally began selling Americans its vehicles with Isuzu badging in the early 1980s. There were Isuzu cars, sure, but the P'up pickup and (starting in 1984) the Trooper SUV showed that Isuzu was likely to rake in the most yen by selling trucks on this side of the Pacific. The three-door convertible Amigo appeared here in 1989, but it was a little too small and silly to sell much among the suburban-commuter set. For the 1991 model year, a five-door Amigo sibling showed up: the Rodeo. The early Rodeo is getting quite rare today, but I was able to find this fairly clean '94 in a Denver-area self-service yard a few months back. These trucks, which were based on the same chassis as the P'up (known as the Isuzu Pickup after 1987) sold well in Colorado. You could get the first-generation Rodeo with rear-wheel-drive, but the four-wheel-drive version made more sense if you wanted to slog through snow and mud in the Rockies (or just feel safe when crossing a parking lot dusted with the white stuff). This truck has true four-wheel-drive, not what eventually became known as all-wheel-drive, but at least the higher trim levels had automatic locking hubs instead of the manual sort that forced you to stop and kneel in the mud to switch. Americans loved automatic transmissions nearly as much in 1994 as we do today, but they cost a lot more relative to manuals back then. This truck has a five-speed manual. The MSRP on this truck was $19,249, or about $39,075 in 2022 dollars. If you wanted it with an automatic transmission, the price went up to $20,349 ($41,310 today). The air conditioning in this one cost an additional 850 bucks (1,725 bucks now). The engine is an Isuzu 3.2-liter V6, rated at 175 horsepower. This truck was built at Subaru-Isuzu Automotive in Indiana; Subaru eventually bought out Isuzu's share of the joint venture and now only Subaru models are built there. Just to add another manufacturer to the mix, Honda sold rebadged Rodeos with Passport badges (and rebadged Troopers as Acura SLXs). This one was well-cared-for, looking clean for a machine with close to 200,000 miles on the clock. We can assume that some costly mechanical ailment finally sent it to this, its final parking place.