2010 Hyundai Sonata Limited Sedan 4-door 3.3l on 2040-cars

Auto blog

US expands probe into ZF-TRW airbag failure-to-deploy to 12.3 million vehicles

DETROIT — U.S. auto safety regulators have expanded an investigation into malfunctioning airbag controls to include 12.3 million vehicles because the bags may not inflate in a crash. The problem could be responsible for as many as eight deaths. Vehicles made by Toyota, Honda, Kia, Hyundai, Mitsubishi and Fiat Chrysler from the 2010 through 2019 model years are included in the probe, which was revealed Tuesday in documents posted by the National Highway Traffic Safety Administration. It involves airbag control units made by ZF-TRW that were installed in the vehicles. The control units can fail in a crash, possibly because of unwanted electrical signals produced by the crash itself that can disable an air bag control circuit housed in the passenger compartment, according to NHTSA documents. The electrical signals can damage the control circuit, the documents say. ZF, a German auto parts maker which acquired TRW Automotive in 2015, said in a statement that it's committed to safety and is cooperating with NHTSA and automakers in the investigation. The case is another in a long list of problems with auto industry airbags, including faulty and potentially deadly Takata airbag inflators. At least 24 people have been killed worldwide and more than 200 injured by the inflators, which can explode with too much force and hurl dangerous shrapnel into the passenger cabin. The inflators touched off the largest series of automotive recalls in U.S. history involving with as many as 70 million inflators to be recalled by the end of next year. About 100 million inflators are to be recalled worldwide. On April 19, NHTSA upgraded the ZF-TRW probe from a preliminary evaluation to an engineering analysis, which is a step closer toward seeking recalls. So far, only Hyundai and Kia and Fiat Chrysler have issued recalls in the case. Four deaths that may have been caused by the problem were reported in Hyundai-Kia vehicles and three in Fiat Chrysler automobiles. NHTSA opened an investigation in March of 2017 involving the TRW parts in Hyundais and Kias. The upgrade came after investigators found two recent serious crashes involving 2018 and 2019 Toyota Corollas in which the airbags did not inflate. One person was killed. Jason Levine, executive director of the Center for Auto Safety, a nonprofit consumer group, said the ZF-TRW case shows the auto industry thus far has learned very little from Takata.

Hyundai reveals new Sonata Hybrid in Seoul

The wraps are off Hyundai's next-generation Sonata Hybrid after an unveiling in Seoul, South Korea, and the latest model brings an improved powertrain and slight styling tweaks. In the Korean domestic market, the Sonata Hybrid relies upon a 2.0-liter, four-cylinder gas engine producing 154 horsepower and 140 pound-feet of torque with a 51-hp electric motor providing the rest of the thrust. Hyundai isn't revealing net system output at the moment, and it isn't saying whether we will get this powertrain in the US yet. Company spokesperson Jim Trainor tells Autoblog that those details will likely be announced at the model's North American debut at Detroit Auto Show in January. Sales are expected to begin in the spring. In addition to the upgraded engine, there's an improved six-speed automatic that houses most of the hybrid components and uses a new clutch to reduce drag. The switch to an electric oil pump also removes some inefficiencies, and the battery pack underneath the trunk has been enlarged to 1.62 kilowatt hours, up from 1.43 kWh. Despite the capacity increase, Hyundai claims there's 10.5 percent more cargo room back there. The Sonata's design gets a slight rethink to improve fuel economy, too. Up front, the redone nose features a new mesh grille in a more rectilinear frame, and out back, there's a set of unique taillamps, a lip spoiler and a unique rear diffuser to go along with the full underbody cover that only the pavement sees. If anything, the new hybrid model looks more traditional to our eyes than the standard gas-powered Sonata, which comes as something of a surprise, especially as the previous-generation Sonata Hybrid was markedly more futuristic and divisive in its appearance. In any case, we expect the looks to remain largely the same for the US version, which will likely arrive wearing a 2016 model-year designation. All of the upgrades, boost fuel economy to 18.2 kilometers per liter on the Korean cycle, the equivalent of about 42.8 miles per gallon. Comparatively, the current Sonata Hybrid in Korea is rated at 16.8 km/l (39.5 mpg). Hyundai will also make a big expansion to its electrified slate next year. In addition to the standard Sonata Hybrid, a plug-in version will come later in 2015 – the automaker's first. More details will arrive about the model in Detroit.

Hyundai tops VW and Buick in China, survey says

You may be aware of the long-time competition in China between Volkswagen and Buick, but another brand apparently should be in that conversation too: Hyundai. In a recently published annual consumer survey, the Korean company actually took the top spot to beat out its German and American rivals in second and third, respectively. The results were part of the China Brand Power Index that interviewed 11,500 people around the nation and was paid for by the country's Ministry of Industry and Information Technology. While Hyundai proved popular with voters, its sales haven't necessarily shown that yet. According to Bloomberg, the brand had falling numbers in China for the first quarter of the year. Even Ford outsold the South Korean automaker in the same period, despite scoring lower on the survey. Meanwhile, Audi ranked as the populace's favorite luxury brand, which is hardly a surprise given the Four Rings' strong sales in China. In January alone the automaker saw a 15-percent boost in volume there. Parent company VW's strong performance was somewhat more surprising, though. State media severely criticized the German automaker in March, and customers protested last year for the allegedly poor handling of a recall.