2006 Honda Odyssey Ex-l on 2040-cars

Auto blog

530,000 Hondas, Acuras under expanded NHTSA investigation for steering problem

Earlier this year, the National Highway Traffic Safety Administration opened an investigation into the 2022 and 2023 Honda Civic. The agency had received 145 complaints from owners stating that the car suddenly exhibited “sticky steering” and increased steering effort. WeÂ’re now learning that the investigation is expanding to include hundreds of thousands more cars. The original probe included around 238,000 Civics, but the NHTSAÂ’s latest report, issued Friday, noted that the investigation is expanding to include more than 530,000 Hondas and Acura vehicles. The 2022 and 2023 Honda Civic, 2023 Honda CR-V, and 2023 Acura Integra are affected. A drastic increase in complaints drove the expansion, as the NHTSA said it had received 1,300 reports and was aware of at least 14 crashes related to the problem. An alarming 11 of those crashes involved a roadway departure due to loss of steering control. Two of them came after the driver allegedly overcorrected, and there are three known injuries from the crashes. NHTSAÂ’s report found that the problem happened primarily in the winter months and after the car had been driven in a straight line for an extended period to warm up the vehicle and gear. Though alarming, itÂ’s worth noting that this investigation has not yet reached the recall stage. Honda acknowledged the problem, noting that it was a manufacturing issue for the steering gear unit. The manufacturing process created conditions that could cause greater internal stress, which can wear and deform the gears inside the steering component. The NHTSA also found that the factory did not guarantee consistent lubrication throughout the gear, which could be the cause of the temporary increase in steering effort. The automaker directed its dealers to replace the electronic power steering gearbox to correct a manufacturing defect, but NHTSA will continue its process, moving to an engineering analysis. If that study finds a defect, it could request a recall. Government/Legal Acura Honda Safety

Mid-engine Honda sports car surfaces in EU patent drawings

Based on new patent drawings, Honda clearly isn't done with sports cars. The design you see above was registered and published by the European Union Intellectual Property Office (EUIPO) and was first reported by AutoGuide. The drawings show a rakish, angular sports car design that is very clearly mid-engine. It could almost pass for a Lamborghini. But the name on the design is Honda Motor Company, and aside from the name, it bares a strikingly similar appearance to a mid-engine design found in a Honda patent two years ago. In fact, the only major difference between this car and the older one (seen below) is the lack of a windshield and top. The shape of the lights and the grille, as well as the front fender vent and character lines running from it, are reminiscent of the S660 kei roadster for Japan. The large, angular intakes look more related to the Acura NSX, though. View 6 Photos Unlike the previous patent renderings of the car, this one has an interior, and the inclusion of it may be why the top and windshield are absent. The interior also leads us to believe that this design is for an upcoming concept. The steering wheel is a small, rectangular piece similar to what you would find in an F1 car or Indy car. The seats also look like thin buckets designed to be as sporty and light as possible. A production version would probably have a bit more cushioning and a round wheel. It does look like there is a pushbutton transmission setup in the center console like current Acuras, though. So what does this mean? Honda is clearly still working on this design, and based on some of the more radical design choices for the interior, we're likely looking at a concept car that will show up in the next couple of years. Whether a concept will lead to a production car is tough to say. There's definitely room in Honda's global sports car roster between the S660 and NSX for something in between, and Honda has reported that it's getting pressure from dealers for sporty cars. The exterior design isn't so extreme it couldn't be tweaked for production, either. There have also been rumors that Honda is preparing a mid-engine hybrid sports car with the Type R's turbocharged four-cylinder. Honda also holds a trademark for the name "ZSX," which fits the naming scheme of the NSX and old RSX, but at least in Europe, Honda has held the trademark since 2009. We'll just have to wait and see what Honda does.

Honda underreported 1,729 claims of injuries or deaths since 2003

Among these underreported cases were eight Takata airbag inflator ruptures not submitted. Following an independent audit of its safety reporting procedures, Honda has found massive holes in its methodology and practices that resulted in 1,729 claims of injuries or deaths going unreported to federal authorities dating back to July 2003. The cases should have been submitted to the National Highway Traffic Safety Administration as part of its quarterly Early Warning Reports (EWRs) under the TREAD Act, but they fell through the cracks for a variety of reasons. Honda blames the underreporting on three factors: data entry errors, computer coding problems and "an overly narrow interpretation of what constituted a 'written notice' under the TREAD Act." The first two issues were related to the computer program that collected the claims. If employees didn't enter a date in the "written claim received" field, then they were omitted from the EWRs. Also, the company's internal component codes didn't always match those used by NHTSA, and only the ones that were the same were disclosed. Finally, third-party documents, including police reports, were not considered. Honda says the computer error is now corrected, and the company is updating its data entry training. In the future, written and oral claims will be included in EWRs, as well. Among these underreported cases were eight Takata airbag inflator ruptures not submitted in Honda's EWRs, including one death and seven injuries. However, the automaker claims NHTSA was already aware of all of these incidents either from the agency's own records or from the company's notification outside of the EWR process. Unfortunately, this problem could have been stopped much sooner. The issue was first brought to light in 2011 but didn't result in a followup. NHTSA advised the automaker of discrepancies in January 2012, and it still did nothing. This third-party audit wasn't commissioned until September 2014. "Honda acknowledges that it lacked the urgency needed to correct its problems on a timely basis," it says in the announcement. Separately, the Japanese government is starting an investigation, as well. According to Reuters, the Japanese Transport Minister has created a task force to look into the Takata recalls and find out whether Honda under-reported incidents there. Scroll down to read the company's entire statement on the third-party investigation.