1999 Honda Odyssey Ex 3.5l V6 7-passenger Alloys 67k Mi Texas Direct Auto on 2040-cars

Auto blog

Honda is spending $124 million on a new wind tunnel facility in Ohio

Ford isn't the only company building a multi-million dollar wind tunnel this year. Honda is also getting in on the action. Its new facility will cost less than Ford's at $124 million, and construction begins this summer. It will be built at the Transportation Research Center in Ohio, which is where Honda's NSX proving grounds are located. Honda will install a five-belt rolling road in the tunnel for testing of more pedestrian vehicles, and a wide, high-speed, single belt version for testing of sports cars and race cars. However, it seems the Honda facility will only be capable of testing wind speeds of up to 192 mph, whereas Ford claims a top speed of 200 mph. Cameras and microphones will also be set up inside the testing area at the Honda tunnel to help find wind noise trouble spots. Honda won't necessarily be the only company using the new wind tunnel either. The facility will be available for other groups and companies to use. There are even secure bays those groups can use for their work. Related Video:

US expands probe into ZF-TRW airbag failure-to-deploy to 12.3 million vehicles

DETROIT — U.S. auto safety regulators have expanded an investigation into malfunctioning airbag controls to include 12.3 million vehicles because the bags may not inflate in a crash. The problem could be responsible for as many as eight deaths. Vehicles made by Toyota, Honda, Kia, Hyundai, Mitsubishi and Fiat Chrysler from the 2010 through 2019 model years are included in the probe, which was revealed Tuesday in documents posted by the National Highway Traffic Safety Administration. It involves airbag control units made by ZF-TRW that were installed in the vehicles. The control units can fail in a crash, possibly because of unwanted electrical signals produced by the crash itself that can disable an air bag control circuit housed in the passenger compartment, according to NHTSA documents. The electrical signals can damage the control circuit, the documents say. ZF, a German auto parts maker which acquired TRW Automotive in 2015, said in a statement that it's committed to safety and is cooperating with NHTSA and automakers in the investigation. The case is another in a long list of problems with auto industry airbags, including faulty and potentially deadly Takata airbag inflators. At least 24 people have been killed worldwide and more than 200 injured by the inflators, which can explode with too much force and hurl dangerous shrapnel into the passenger cabin. The inflators touched off the largest series of automotive recalls in U.S. history involving with as many as 70 million inflators to be recalled by the end of next year. About 100 million inflators are to be recalled worldwide. On April 19, NHTSA upgraded the ZF-TRW probe from a preliminary evaluation to an engineering analysis, which is a step closer toward seeking recalls. So far, only Hyundai and Kia and Fiat Chrysler have issued recalls in the case. Four deaths that may have been caused by the problem were reported in Hyundai-Kia vehicles and three in Fiat Chrysler automobiles. NHTSA opened an investigation in March of 2017 involving the TRW parts in Hyundais and Kias. The upgrade came after investigators found two recent serious crashes involving 2018 and 2019 Toyota Corollas in which the airbags did not inflate. One person was killed. Jason Levine, executive director of the Center for Auto Safety, a nonprofit consumer group, said the ZF-TRW case shows the auto industry thus far has learned very little from Takata.

Honda safety campaign hunting for faulty Takata airbags in junkyards

Honda has been working for months to recall about 5.5 million vehicles to replace their faulty Takata airbag inflators. With many of these models dating back over a decade, some of them aren't on the road anymore; instead they're sitting in salvage yards across the country as a possible source for inexpensive, recycled parts. There's a serious risk for injuries and fatalities if these bad components end up in cars still on the road, and the automaker is on the hunt to track the dangerous parts down. According to Automotive News, Honda thinks there could be over 24,000 recalled Takata airbags in the company's vehicles in junkyards in the US. The automaker has been working with an outside business to find them and issued notices to salvage lots around the country about an offer to buy the parts back. So far, it has tracked down around 3,900 inflators. Bizarrely, Honda is facing pushback on this safety campaign from the Automotive Recyclers Association. "The buyback program appears to be offering recyclers a price for airbags materially lower than the fair parts value," organization CEO Michael Wilson said to Automotive News. Although, under federal law it's illegal to sell faulty components to people. The trade group also has a pending lawsuit against the automaker for alleged lost value in buying vehicles with Takata inflators. In addition to getting the word out to auto recyclers, Honda had a nationwide advertising campaign for people to get their cars fixed. However, the company and Takata are facing many lawsuits for injuries and deaths related to the faulty inflators.