2014 Honda Accord Sport on 2040-cars

Auto blog

US expands probe into ZF-TRW airbag failure-to-deploy to 12.3 million vehicles

DETROIT — U.S. auto safety regulators have expanded an investigation into malfunctioning airbag controls to include 12.3 million vehicles because the bags may not inflate in a crash. The problem could be responsible for as many as eight deaths. Vehicles made by Toyota, Honda, Kia, Hyundai, Mitsubishi and Fiat Chrysler from the 2010 through 2019 model years are included in the probe, which was revealed Tuesday in documents posted by the National Highway Traffic Safety Administration. It involves airbag control units made by ZF-TRW that were installed in the vehicles. The control units can fail in a crash, possibly because of unwanted electrical signals produced by the crash itself that can disable an air bag control circuit housed in the passenger compartment, according to NHTSA documents. The electrical signals can damage the control circuit, the documents say. ZF, a German auto parts maker which acquired TRW Automotive in 2015, said in a statement that it's committed to safety and is cooperating with NHTSA and automakers in the investigation. The case is another in a long list of problems with auto industry airbags, including faulty and potentially deadly Takata airbag inflators. At least 24 people have been killed worldwide and more than 200 injured by the inflators, which can explode with too much force and hurl dangerous shrapnel into the passenger cabin. The inflators touched off the largest series of automotive recalls in U.S. history involving with as many as 70 million inflators to be recalled by the end of next year. About 100 million inflators are to be recalled worldwide. On April 19, NHTSA upgraded the ZF-TRW probe from a preliminary evaluation to an engineering analysis, which is a step closer toward seeking recalls. So far, only Hyundai and Kia and Fiat Chrysler have issued recalls in the case. Four deaths that may have been caused by the problem were reported in Hyundai-Kia vehicles and three in Fiat Chrysler automobiles. NHTSA opened an investigation in March of 2017 involving the TRW parts in Hyundais and Kias. The upgrade came after investigators found two recent serious crashes involving 2018 and 2019 Toyota Corollas in which the airbags did not inflate. One person was killed. Jason Levine, executive director of the Center for Auto Safety, a nonprofit consumer group, said the ZF-TRW case shows the auto industry thus far has learned very little from Takata.

James Glickenhaus' SCG 003 undisguised in street and track form

For James Glickenhaus buying a factory-made supercar isn't good enough; he wants to develop his own. Following up on the Ferrari Enzo-based P4/5 and later the P4/5 Competition, Glickenhaus' latest project is appropriately called the 003, and he's finally displaying it in road trim. These first undisguised photos of the SCG 003S show off a supercar with a front end reminiscent of a Ferrari Enzo. However, the rear evokes the look of a modern endurance racer with a fin running along the spine. A wing at the back connects it all together, and the massive diffuser should keep things planted too. Development of the 003 has been going for over a year by Scuderia Cameron Glickenhaus, but the company has set quite a challenge for itself to get just right. Glickenhaus wants his latest project to be a true racecar for the street. That idea gets thrown around a lot, but it might be true in this case. In motorsports trim, the SCG 003C (pictured inset) packs a mid-mounted Honda Performance Development twin-turbocharged V6, but the engine sits in a detachable rear subframe. When the time comes for the road, the car converts to the SCG 003S and allegedly swaps in a twin-turbo W12. It makes the vehicle the best of both worlds – at least in theory. SCG reportedly plans to show the 003 at the Geneva Motor Show, so we should get a better look then. Glickenhaus also wants to take the car racing in the 24-hour events at the Nurburgring and Spa later this year.

Submit your questions for Autoblog Podcast #317 LIVE!

We record Autoblog Podcast #317 tonight, and you can drop us your questions and comments regarding the rest of the week's news via our Q&A module below. Subscribe to the Autoblog Podcast in iTunes if you haven't already done so, and if you want to take it all in live, tune in to our UStream (audio only) channel at 10:00 PM Eastern tonight.
Discussion Topics for Autoblog Podcast Episode #317
Mitsubishi Mirage