1940 Ford Custom Pickup Truck on 2040-cars

Auto blog

Ford recalls more than 550,000 trucks and SUVs for various safety issues

Ford announced safety recalls for its current F-150 pickup along with several Ford and Lincoln crossovers early Wednesday. The recalls cover more than 550,000 vehicles and address various safety defects, ranging from a fire hazard to potential loss of braking power.  The most far-reaching of the recalls covers approximately 550,000 examples of the 2015-2018 Ford Edge and 2016-2018 Lincoln MKX, which may have been assembled with defective front brake jounce hoses (also commonly referred to as "flex lines"). These hoses run from fixed points on the chassis to the individual front brake calipers. Defective hoses could potentially rupture, allowing brake fluid to leak and resulting in a loss of braking function. Ford will replace the components in question with revised parts.  The next-largest recall is for roughly 3,000 2020 Lincoln Corsair crossovers. The affected models may have been assembled without proper clearance between their rear suspension springs and toe link brackets. The components could potentially make contact, wearing down the protective coating on the rear coil springs, allowing corrosion to occur over time. This corrosion could eventually lead to a failure of the spring. If this happens while the vehicle is being driven, it could result in a sudden change to the vehicle's handling characteristics, and the spring fragments could potentially cause further damage to the car or surrounding traffic.  Ford says owners will be notified that their Corsairs need to be inspected; if there is not adequate clearance between the rear suspension components, Ford's service technicians will remove material from the toe link bracket to allow for operation without contact.  The final (and by far the smallest) recall is for the 2020 F-150. Some units may have left the factory with the incorrect retention nut on the hot lead to the starter motor. Ford says it can cause increased heat generation or electrical arcing, which could potentially result in a fire. Ford says this issue is limited to just a few hundred examples sold in the United States. Dealers will inspect the vehicles and replace the nut if necessary.       

Ford 'working very hard' on F-150 hybrid

The lighter, aluminum-bodied 2015 Ford F-150 gets (at best) 26 miles per gallon. That's not bad for a truck that size – and we should always remember that improving gas guzzlers can make a big difference – but what if the popular truck came with a gas-electric hybrid powertrain? How efficient would that be? We heard Ford talking about such a vehicle last year, and now we learn that Ford is still "working very hard" to make a F-150 hybrid happen. You want details? Well, we all want details, but those will not be coming for quite some time. Last year, Ford's global product development chief, Raj Nair, said that the company was planning to have hybrid pickups and hybrid SUVs on sale by 2020. With fuel prices dropping, Nair is now saying that a hybrid F-150 makes more sense, financially, than a diesel, but Ford could make both options available, depending on customer demand. The diesel wouldn't require all that much work, Nair said, since "we've got diesels in the portfolio." To date, the only hybrid F-150s we've seen have been conversions, often PHEVs, like this example from HVET or this one from Quantum. Pickup trucks from other manufacturers haven't been greeted with huge sales numbers. General Motors stopped making its big two-mode hybrids and cancelled the next-gen program.

2015 Ford F-150 to get up to 26 miles per gallon

The 2015 Ford F-150 is one of the most important US vehicle debuts in years, be it in the pickup segment or the entire marketplace. While we've already known about the truck's engine lineup, its payload ratings and we've even learned a bit about how it drives, the truck's EPA-estimated fuel economy ratings have remained a mystery. The wait is finally over. Ford has announced numbers that put the latest F-150 as the mileage leader among gasoline-powered, full-size pickups in the US, with its new 2.7-liter EcoBoost V6 topping the charts. Starting with the entry-level naturally aspirated 3.5-liter V6, the rear-wheel-drive F-150 is rated at 18-miles-per-gallon city, 25-mpg highway and 20-mpg combined. Opting for four-wheel drive drops those numbers slightly to 17/23/19. If fuel economy is your absolute priority, then upgrading to the 2.7-liter EcoBoost V6 is the hot ticket. It improves things further to 19/26/22 in rear-wheel drive trim or 18/23/20 with four-wheel drive. The carryover naturally aspirated 5.0-liter V8 is rated at 15/22/18 as a 4X2 or 15/21/17 as a 4X4. Finally, the flagship 3.5-liter EcoBoost V6 tops the range in available torque and offers buyers 17/24/20 ratings with rear-wheel drive or 17/23/19 with four-wheel drive. "We are delivering with the toughest, smartest and most capable F-150 ever – and now the highest EPA-estimated fuel economy ratings of any full-size gas-powered pickup in America," said Raj Nair, Ford group vice president, Global Product Development, in the company's announcement. Depending on engine and drivetrain configuration, Ford contends that the 2.7-liter EcoBoost's top rating puts fuel economy up between 5 and 29 percent over the current generation, thanks in large part to the truck's lighter aluminum construction. Obviously, these are EPA estimates, and your mileage may vary – ours has. Recently, Autoblog team members have had real difficulty even approximating government mpg estimates on many EcoBoost models, including the new F-150. Scroll down to read Ford's full announcement, including comparisons to rival models.