One Owner,clean Carfax, Topless Mustang** Rates As Low As 1.89% Nationwide! on 2040-cars

Auto blog

Ford recalls more than 550,000 trucks and SUVs for various safety issues

Ford announced safety recalls for its current F-150 pickup along with several Ford and Lincoln crossovers early Wednesday. The recalls cover more than 550,000 vehicles and address various safety defects, ranging from a fire hazard to potential loss of braking power.  The most far-reaching of the recalls covers approximately 550,000 examples of the 2015-2018 Ford Edge and 2016-2018 Lincoln MKX, which may have been assembled with defective front brake jounce hoses (also commonly referred to as "flex lines"). These hoses run from fixed points on the chassis to the individual front brake calipers. Defective hoses could potentially rupture, allowing brake fluid to leak and resulting in a loss of braking function. Ford will replace the components in question with revised parts.  The next-largest recall is for roughly 3,000 2020 Lincoln Corsair crossovers. The affected models may have been assembled without proper clearance between their rear suspension springs and toe link brackets. The components could potentially make contact, wearing down the protective coating on the rear coil springs, allowing corrosion to occur over time. This corrosion could eventually lead to a failure of the spring. If this happens while the vehicle is being driven, it could result in a sudden change to the vehicle's handling characteristics, and the spring fragments could potentially cause further damage to the car or surrounding traffic.  Ford says owners will be notified that their Corsairs need to be inspected; if there is not adequate clearance between the rear suspension components, Ford's service technicians will remove material from the toe link bracket to allow for operation without contact.  The final (and by far the smallest) recall is for the 2020 F-150. Some units may have left the factory with the incorrect retention nut on the hot lead to the starter motor. Ford says it can cause increased heat generation or electrical arcing, which could potentially result in a fire. Ford says this issue is limited to just a few hundred examples sold in the United States. Dealers will inspect the vehicles and replace the nut if necessary.       

How Ford's light lab keeps the sun shining on the new Mustang just right [w/video]

Anyone who's bought one of those old school metal shift knobs knows they're really cool until they sit in a parking lot in the sun for a few hours. Then they're not cool at all. Likewise, features such as the aluminum dash on the 2015 Ford Mustang can be all kinds of neat right up until the sun hits it just the right way and sends shards of blinding light through the cabin. The Ford Visual Performance and Evaluation Lab is where engineers figure out how to make sure that doesn't happen.
Cars like said Mustang are parked inside the 30-foot reflecting dome under 6,000 watts of lights that can mimic the sun at any time of day and in any weather condition. Engineers can then spend cold, overcast days inside, testing for interior legibility, glare and reflections on every interior and exterior surface as if it were bright and sunny. They can also learn how a car's sheetmetal and colors will look out of doors, all year round.
Ford showed off the lighting lab without the music and interviews three years ago when the Explorer was being prepared. You can watch it at work again in the video below, and read about it in the press release below that.

What next for Alan Mulally?

Alan Mulally has emerged as a hero when it comes to American manufacturing. He came to Ford in 2006 after serving as head of Boeing's commercial aircraft division, streamlined operations, sold off the costly elements of its Premier Automotive Group and saved Ford from having to be bailed out by the federal government like its cross-town rivals Chrysler and General Motors did. But as we reported mere days ago, he's widely expected to step down from the chief executive's office at Ford shortly.
So what's next for one of the most successful executives in the business? Hard to say, but don't expect Mulally to disappear into retirement. Though he didn't ultimately take the top job at Microsoft, industry insiders expect to see him in another influential position - likely as a board director or even chairman of another company. (We say "another company" and not Ford because while Bill Ford may have stepped aside as CEO to bring Mulally on board in the first place, we don't see him giving up his chairmanship of the board also.)
Mulally has likely already lined up his next move, and could either announce what that move will be as soon as Ford confirms Mark Fields as his successor, or could wait awhile. Insiders speculate that he could leverage his transportation and aerospace experience into a position at General Electric or a major airline, his manufacturing expertise to benefit a company like Procter & Gamble or his management skills at a consultancy firm.