2014 Ford Mustang on 2040-cars

Auto blog

A cool boost to turbocharger performance

Since the advent of the forced-induction engine, we have been looking for ways to get every drop of performance we can. There are many approaches to getting additional power using better intercooling, water injection, or even adding nitrous oxide. One take on a short instant burst of power is being researched by Mahle and involves providing supercooled air to an engine, which allows it to burn a leaner fuel mixture and produce more power. The supercooling idea is not new and was examined by Ford in 1993 on the Mustang Mach III concept car, then brought up again in 2003 with the SVT F-150 Lightning concept. Ford called its system the SuperCooler; it was designed to work with any turbocharged or supercharged engine equipped with a water-to-air intercooler. The system on the Lightning concept used a small tank of antifreeze that was hooked up to the truck air conditioning compressor. The air conditioning compressor cooled the antifreeze down to about 30 degrees. The other side of the tank was hooked up to the air-to-water intercooler, which usually had a temperature over 100 degrees. Once the antifreeze was circulated from the tank into the intercooler, it would lower the intercooler temperature and provide for a cooler, denser air charge into the engine; the result was around 50 extra horsepower for a burst of about 30 seconds to a minute, depending on the size of the tank. The system for the Lightning was to be offered as a $750 option and would have been targeted towards drag racers and the like, as it could be used for a run down the drag strip and then re-cooled by the time the truck was back in line. The system was fairly non-intrusive – it only weighed about 25 pounds and did not require a new compressor or intercooler. But as with many concepts, it was ultimately scrapped. The technology was always stuck in the back of my mind, but with larger and more powerful engines being produced it could not find its place. With the advent of new fuel economy standards, we have seen small-displacement turbocharged engines pop up and they seem like the perfect candidate for this type of technology. Ford's EcoBoost 1.0-liter three-cylinder turbocharged engine, as used in the Fiesta and Focus, is one such candidate for this technology. It would add a negligent amount of weight but could provide a boost of 10 to 20 horsepower when needed, like merging onto the highway or catching up to traffic.

Ford's new Focus RS hatches hot and heads for America

The hot hatch market is heating up, and heating up fast. What you see here is Ford's new challenger for pocket-rocket supremacy, the third iteration of the breed and the 30th model to wear the Rallye Sport designation. But perhaps best of all, it will be the first time Ford will offer a new Focus RS in America. Following yesterday's leak, the latest Ford Focus RS is now ready to step out into the light and light up its tires. Answering the call is the same 2.3-liter EcoBoost turbo four as you'd find in the new Mustang, but upgraded with a new low-inertia twin-scroll turbocharger, larger compressor and intercooler, freer-flowing intake, large-bore dual-pipe exhaust with electronically controlled valve and upgraded internal components. The result is a 6,500-rpm redline (closer to that of Ford's atmospheric performance engines) and an output quoted as "well in excess of 315 horsepower" – which is already 5 more than the EcoBoost Mustang and a good 63 more than the existing Focus ST. Power is transmitted to the tarmac through a new performance-focused all-wheel drive system with torque vectoring that can send as much as 70 percent of available twist to the rear wheels (and as much as 100 percent between them). The system works in tandem with the brake-based torque vectoring system and stability control, and will even divert torque to the outside rear wheel under cornering to keep it flat and under control while reducing understeer. Those still suspicious of dual-clutch gearboxes will also be pleased to read that Ford has stuck with a conventional six-speed manual. We'll reserve judgement on the inclusion of the electric power steering until we get a chance to drive it, though. Of course the small team of global Ford Performance engineers who developed the new Focus RS – and the Gymkhana legend Ken Block who consulted on the project – didn't just tinker with the powertrain and leave it at that. The suspension features stiffer spring rates, bushings and anti-roll bars than the Focus ST, augmented by two-mode switchable dampers. 19-inch alloys wear Michelin Pilot Super Sport rubber, with optional Pilot Sport Cup 2 semi-slicks for track-day enthusiasts. Ford has yet to detail the brakes on its new hot hatch, but you can bet they've been upgraded as well.

Ford's Simple Suit Makes You Feel Like A Drunk Driver

We've all heard about the dangers of drunk driving for practically our entire lives. Whether it's from PSAs on TV or lectures in school, no one can claim ignorance of drunk driving being extremely dangerous. However, that doesn't prevent some people from still doing it. Ford is trying to take the safety message directly to young drivers with a special suit that allows them to simulate driving under the influence. It is all part of Ford's Driving Skills for Life program that gives free driving education to young people. The program is meant to "train kids in skills they don't learn in driver's ed," said Kelli Felker, Ford Safety Communications Manager, to Autoblog. The drivers don a few items to impair their senses and make them off-balance to simulate having a few too many drinks and then go out on a closed course with an instructor to see the effects. Felker said that the suit is a new part of the program, and Ford just received the outfit in the US. It will be incorporated into the training here in the late spring or early summer. Scroll down to see the effect it has on drivers in Europe. This content is hosted by a third party. To view it, please update your privacy preferences. Manage Settings.