1929 Ford Model A 4 Dr A1138935phaeton on 2040-cars

Auto blog

Ford recalls 434k vehicles for several unrelated issues

It seems that the hard winter in much of the country has been as rough on some Fords as it has on many people. The Blue Oval is recalling roughly 434,000 vehicles in two separate recalls, and one of them partially caused by the salt used to melt the snow on roads.
The first recall covers 385,750 2001-2004 Escape models in the Midwest, Northeast and Canada because a subframe could rust and eventually fail. This is partially due to the road salt used in those areas, and about 349,000 of the affected vehicles are in the US. To remedy the problem, dealers are installing a reinforcement cross brace on the frame to strengthen them. There has been one crash caused by the failure but no injuries. According to The Detroit News, this is not the first rust-related recall for Ford. It estimates the company has repaired over two million vehicles since 2010 for problems on vehicles related to the iron oxide, including the rear wheel wells of the Freestar minivan.
The second recall covers 48,950 2013-2014 Ford Fusion, Escape, C-MAX and Lincoln MKZ models because welds in their seatbacks don't meet National Highway Traffic Safety Administration standards. The fault affects the front seats, and the sub-standard welds joining the setback to the recliner could increase the chance on injury. There have been no reported injuries or accidents caused by the problem, but there are 42,972 affected vehicles in the US and 4,744 in Canada.

Ford, Samsung shack up to bring regen braking to non-hybrid models [w/video]

Ford must be desperate to get itself ready for the beach this summer because it is really trying to get into shape. Shortly after unveiling the Lightweight Concept that cut the weight of a Fusion down to that of a Fiesta, it's now the rest of the line's turn for improvement. The company is wrapping up a 10-year research project aimed at developing next-gen automotive batteries to improve efficiency.
Ford claims that 70 percent of its lineup will have stop/start tech by 2017. The key to this massive proliferation is its new dual-battery system that combines a lithium-ion battery with a lead-acid one and regenerative braking. The setup works by harvesting braking energy and converting it to electricity. When the vehicle stops, the engine shuts off, but the Li-ion battery has enough juice to keep the accessories running. The engine starts up again as drivers take their foot off the brake. The layout would mean less wasted gas while idling. It's already available on Ford hybrids and is somewhat similar to the i-Eloop capacitor-based system from Mazda.
The bigger challenge is tuning the regenerative braking right. While hybrid drivers may be a little more adventurous, when it comes to getting a hang of regen braking, conventional buyers might not be so open-minded. The systems have a tendency to be a little grabby at first and then taper off at very low speeds. Ford needs to make sure it's just right to avoid turning off buyers.

Ford books $1.2B profit in second quarter on strength of trucks

Ford is rolling along nicely, with a positive second-quarter sales report and a $2.3 billion profit in North America. The Dearborn, Michigan-based manufacturer captured $1.2 billion globally from April to June, with a $177 million profit in Asia. Even in Europe, the land of doom and gloom for automakers not named Mazda, Ford saw some success as it lowered its expected full-year loss from $2 billion to $1.8 billion. The company lost $348 million in Europe during the second quarter, which, believe it or not, represents a $56-million improvement over 2012.
According to the report on CNBC, Ford enjoyed a three-percent increase in pre-market trading thanks to the news. The strong demand for the F-150 propelled growth in the US market, while Ford's 47-percent increase in Asian sales can be attributed to the new EcoSport crossover and Kuga (Ford Escape in the US) arriving in the somewhat fragile Chinese market.
Pre-tax profits for Ford are expected to be in the neighborhood of $8 billion by the end of the year, with sales the US, Europe, and China all looking up. The company also shifted $4.78 billion of asset-backed debt in the form of bonds, according to a report by Bloomberg. This move came amidst rumors of the Federal Reserve cutting back on its $85-billion-per-month bond purchases. Ford wasn't alone among automakers looking to sell off debt, though, as Mercedes-Benz and Nissan shifted around $1 billion each in bonds relating to auto loans.