Fiesta, 5 Passenger, Low Mileage, 4 Cylinder on 2040-cars

Auto blog

2017-19 Ford Super Duty trucks recalled for tailgates that could open

Ford announced two separate recalls today, though neither has resulted in any known injuries. The first recall, which deals with a tailgate malfunction, affects 261,617 examples of 2017-2019 F-250, F-350, and F-450 Super Duty pickups. The second, which anticipates the possibility of a fuel leak, affects 3,893 units of 2020 Explorer and 2020 Lincoln Aviator SUVs with 3.0-liter engines. Ford says tailgates might accidentally open on some 2017-2019 Super Duty trucks because of a short circuit. If the pickups have an electric tailgate latch-release switch on the tailgate handle, water might get into the wiring. If the water hits the right spots, a short circuit could cause the switch to release the tailgate latch. In a worst-case scenario where the tailgate opens while driving, contents of the truck's bed could fall out and create a safety hazard. Dealerships will fix the problem by modifying the tailgate frame wiring harnesses with jumper pigtails and install a new tailgate handle release switch. Of the lot, 231,664 trucks are in the U.S., and 29,953 are in Canada. The Ford recall number is 19S48.  The second recall is much smaller, involving fewer than 4,000 vehicles. In certain 2020 Explorers and Aviators with 3.0-liter engines, Ford says, "The convolute protective sleeve on the liquid fuel line is not long enough, which may allow for potential hard contact with the convolute-protected vapor fuel line. Over time, with vibration and engine roll, hard contact between the two fuel lines could cause the convolute on the vapor fuel line to rub through the plastic liquid fuel line." If that happens, it could be a fire risk and hazardous for drivers and passengers. Only 35 of those SUVs are in Canada, and the rest are in the United States. Dealers will fix the problem by replacing the defective convolute with a full-length piece and tying it down with a strap. The recall reference number for the Aviators and Explorers is 19S49. The recall adds to what has otherwise been a rocky early production phase for the new Explorers and Aviators.

NHTSA closes Ford F-Series Super Duty steering probe without recall

The National Highway Traffic Safety Administration's investigation into 2008 Ford F-250 and F-350 Super Duty pickups, which was originally opened last year, has now ended without a recall. NHTSA was looking into steering failures on some 336,000 trucks.
The issue rested with the steering gear - NHTSA received five complaints of failures - which was redesigned in 2005. According to the report on the matter, investigators "found evidence of broken sector shaft gear teeth and piston damage consistent with incidents of single event overload."
NHTSA investigators, however, "found no evidence of fatigue or material property defects in any of the fractures. Analysis of complaint rates by vehicle build month showed no patterns indicating potential manufacturing quality issues and no difference before and after Ford introduced design changes to the input shaft and sector shaft seals in July 2007 to address potential leak concerns," according to the report, obtained by The Detroit News.

The 24 Hour War: Adam Carolla's new documentary brings the Ford-Ferrari battle back to life

Long before the GoPro or even videotape, races were filmed by guys standing next to the track with 16-millimeter cameras. The images kind of shook, they didn't always hold focus, and over the years all the color has faded out of the film. It all conspires to make the endurance racing battle between Ferrari and Ford in the 1960s seem like ancient history. What Adam Carolla and Nate Adams' new documentary The 24 Hour War does best is make that inter-corporate battle feel as if it happened yesterday. Yeah, if you're an obsessive you've likely seen most of the shaky-cam race footage used here before. But what you haven't seen are the interviews that frame the war and explain the egos and engineering behind the legends. It's not a perfect movie, but it's the sort of movie only fanatics could make. And it's easier to appreciate if you're a fanatic too. The first 25-or-so minutes of the documentary are taken up with histories of both Ford and Ferrari and an overview of how ridiculously deadly motorsports were in the Sixties and earlier. It's all interesting (if familiar) stuff, that could have been handled in about a third the time with some brutal editing. Still, the two protagonists in the story are well drawn: the racing-crazed Enzo Ferrari, who only builds road cars to stay solvent; and Henry Ford II, who after being thrown into the deep end of the Ford Motor Company management in 1943 at the age of 25, wasn't going to be humiliated after Ferrari pulled out of a deal to sell him the sports car maker. With one notable exception, the filmmakers were successful in rounding up practically everyone involved who is still alive for an interview. That includes Dan Gurney, Mario Andretti, Pete Brock, Bob Bondurant, Piero Ferrari, Mauro Forghieri, Carlo Tazzioli, and even Ralph Nader. There are good archival insights from the late Carroll Shelby. But where's A.J. Foyt? After all, he co-drove the stupendous Ford GT40 Mark IV with Dan Gurney to victory at Le Mans in 1967. The interviews make the movie worthwhile, but it cries out for more technical depth about the cars themselves. Yes, the GT40 was complex and engineered practically like a production car, but there's no mention of how the Lola Mk VI and Eric Broadley kicked off the development. There's only a superficial explanation of what made the American-built Mark IV such a leap forward.