2014 Ford Fiesta S on 2040-cars

Auto blog

NHTSA and Ford investigating steering issues in Crown Vic, Grand Marquis and Marauder

There may be more steering woes for the Ford Crown Victoria. The National Highway Traffic Safety Administration has opened a preliminary evaluation into the Crown Vic and Mercury Grand Marquis from the 2004 to 2007 model years and the Mercury Marauder for the 2004 and 2005 model years because the steering shaft can jam. The issue could potentially affect an estimated 500,000 vehicles.
According to the regulator, there is a possibility that the driver's side heat shield for the exhaust manifold can rust, dislodge, and then wedge into the steering shaft. If this occurs, it leads to a situation where the driver can no longer control the car.
NHTSA has received five complaints of this happening, including one alleged case with an injury. In that situation, the car was driving onto the highway, lost control and rolled over. One occupant was hurt in the accident.

GM, Ford, FCA and the UAW form joint coronavirus task force

General Motors, Ford and Fiat Chrysler are forming a coronavirus task force along with the United Auto Workers union to improve protections for their employees and limit the spread of the highly contagious virus. The task force, which would be focusing on areas including vehicle production plans, is being headed by UAW President Rory Gamble, GM Chief Executive Officer Mary Barra, Ford CEO Jim Hackett, Ford Executive Chairman Bill Ford and FCA CEO Michael Manley, the parties said in a joint statement on Sunday. Though automakers typically schedule plant staffing to allow for a certain proportion of absent workers, according to industry consultants, if the outbreak causes higher levels due to infection or workers staying home to care for children whose schools are closed, that could lead to reduced production or in extreme cases shutdowns. Production at an FCA assembly plant in Canada was halted for 24 hours after employees there refused to work on Thursday over fears of an employee being possibly exposed to the coronavirus. Separately on Thursday, the Italian-American automaker said that one of its employees had tested positive for COVID-19, a respiratory disease caused by the new coronavirus, at its transmission plant in Indiana. The plant, however, remained open. "This is a fluid and unprecedented situation, and the task force will move quickly to build on the wide-ranging preventive measures we have put in place," the CEOs of the three companies said in the statement. The task force would also be focusing on aspects such as health and safety education, health screening, food service at the automakers' locations. Related Video: Government/Legal Plants/Manufacturing UAW/Unions Chrysler Fiat Ford GM coronavirus

Ford recalls more than 550,000 trucks and SUVs for various safety issues

Ford announced safety recalls for its current F-150 pickup along with several Ford and Lincoln crossovers early Wednesday. The recalls cover more than 550,000 vehicles and address various safety defects, ranging from a fire hazard to potential loss of braking power.  The most far-reaching of the recalls covers approximately 550,000 examples of the 2015-2018 Ford Edge and 2016-2018 Lincoln MKX, which may have been assembled with defective front brake jounce hoses (also commonly referred to as "flex lines"). These hoses run from fixed points on the chassis to the individual front brake calipers. Defective hoses could potentially rupture, allowing brake fluid to leak and resulting in a loss of braking function. Ford will replace the components in question with revised parts.  The next-largest recall is for roughly 3,000 2020 Lincoln Corsair crossovers. The affected models may have been assembled without proper clearance between their rear suspension springs and toe link brackets. The components could potentially make contact, wearing down the protective coating on the rear coil springs, allowing corrosion to occur over time. This corrosion could eventually lead to a failure of the spring. If this happens while the vehicle is being driven, it could result in a sudden change to the vehicle's handling characteristics, and the spring fragments could potentially cause further damage to the car or surrounding traffic.  Ford says owners will be notified that their Corsairs need to be inspected; if there is not adequate clearance between the rear suspension components, Ford's service technicians will remove material from the toe link bracket to allow for operation without contact.  The final (and by far the smallest) recall is for the 2020 F-150. Some units may have left the factory with the incorrect retention nut on the hot lead to the starter motor. Ford says it can cause increased heat generation or electrical arcing, which could potentially result in a fire. Ford says this issue is limited to just a few hundred examples sold in the United States. Dealers will inspect the vehicles and replace the nut if necessary.