Crew Cab Lariat 4x4 Powerstroke Diesel Leather Nav Roof Low Miles Clean on 2040-cars

Auto blog

Ford and Lincoln recall about 170,000 vehicles over defective rear-view camera

Ford and Lincoln have jointly issued a safety recall that includes nearly 170,000 vans and SUVs built between the 2018 and 2023 model years. The vehicles included in the campaign are equipped with a rear-view camera whose image can cut out while the driver is backing up. Assigned recall number 23V-598 by the National Highway Traffic Safety Administration (NHTSA), the campaign includes the following cars: 7,649 units of the 2020-2023 Aviator fitted with the standard rear-view camera and built from October 19, 2019, to August 17, 2023. 70,600 units of the 2018-2021 Navigator fitted with the 360-degree camera and built from March 16, 2017, to December 23, 2021. 66,740 units of the 2022-2023 Transit fitted with either camera system and built from February 26, 2021, to August 17, 2023. 24,468 units of the 2021 Bronco fitted with the 360-degree camera and built from September 23, 2020, to December 22, 2021. Ford explains that the defect is present in all of the 169,277 vehicles included in the campaign. While these are different cars equipped with different technology, they all suffer from the same problem. The company explains that "customers may intermittently experience either a rear camera blue image or a full blue or black image on the SYNC [infotainment system] screen when the vehicle is placed in reverse, or when the 360-degree view is selected and available." It adds that losing the camera's image while backing up increases the risk of the crash. The cause of the problem varies from model to model. Ford has narrowed it down to the camera hardware, the wiring retention, and the Image Processing Module - V (IPMB) software. It adds that "fretting corrosion causes tin oxide formation on the internal camera connector due to [a] thermally-induced micro-movement between the tin-plated contact surfaces," and that the rate of tin oxide accumulation depends on factors such as the temperature and the humidity. It has also traced some of these issues to a problem during the manufacturing process. Ford will begin notifying owners of affected vehicles by mail on October 2. When parts are available, owners will be asked to bring their van or SUV to an authorized dealer so that a technician can replace the rear-view camera. Transit models included in the campaign will also receive a software update. Owners who have already paid to fix the problem can claim a reimbursement until June 30, 2024. This isn't Ford's first rear-view camera-related recall.

Ford Explorer, Jeep Grand Cherokee flunk IIHS passenger-side crash test

The Insurance Institute for Highway Safety (IIHS) has uncovered major safety-related problems while crash testing a number of popular midsize SUVs. Among those that scored an overall rating of "poor," the lowest possible score, are the Ford Explorer and Jeep Grand Cherokee. Both SUVs showed a high risk of injury to a front passenger during the IIHS' passenger-side small overlap front crash test. This test simulates what might happen if a car or SUV strikes an immovable object, like a telephone pole, at 40 mph and with roughly 25-percent of its front width. "Although some vehicles in this group offer very good protection, in other models, the airbags, safety belts and structure showed serious deficiencies," says IIHS chief research officer, David Zuby. "In those SUVs, a front-seat passenger would be at risk of injuries to the head, hip or leg in a right-side small overlap front crash." In the 2018 Ford Explorer, the front of the SUV showed the structure was "seriously compromised" during both driver- and passenger-side small overlap crash testing, according to the IIHS. The lower and upper door hinge pillar showed intrusion levels of 15 and 13 inches, while the door sill itself was pushed inward 6 inches toward the crash test dummy. The IIHS states these results indicate a high probability that a front occupant would suffer injuries to their right hip and lower left leg. The 2018 Jeep Grand Cherokee didn't fare much better. Not only did the Jeep exhibit 10 inches of intrusion at the lower door hinge pillar, the front passenger crash test dummy's head hit the dashboard through the front airbag. Worse still, the side curtain airbag didn't deploy and the front passenger door opened. The IIHS says there is a strong chance this would result in right leg injuries, along with the possibility of a serious head injury. Even vehicles that earned an "acceptable" in the small overlap front crash test showed definite room for improvement. The 2018 Honda Pilot, for example, showed good structural performance during the crash itself. But the front passenger crash test dummy's head slid off the deployed airbag and hit the dashboard hard, indicating a head injury might result in a similar real-world crash scenario. Two other SUVs that scored "acceptable" ratings included the 2018 Nissan Pathfinder and 2018 Toyota Highlander. Scoring top marks of "good," the highest rating, in these IIHS crash tests were the 2018 Volkswagen Atlas, 2018 GMC Acadia, and 2019 Kia Sorento.

J Mays retiring from Ford design, succeeded by Moray Callum

Ford's highly influential head of design, J Mays, has announced that he'll be retiring from his position after 33 years in the industry, 16 of which were at the Dearborn, MI-based company. Upon departure, he'll be succeeded as group vice president of design by Moray Callum. If that last name sounds familiar, yes, he's the brother of Jaguar's Ian Callum.
It's difficult to explain just how big of a role Mays had on not just Ford's design over the years, but on the entire industry. Before heading to Dearborn, Mays worked for Audi, BMW and then Volkswagen, where he was involved in concept cars that paved the way for design icons like the first-generation Audi TT and the Volkswagen New Beetle. As for his Ford resume, it's extensive.
Mays joined the company in 1997 as design director for Ford, Lincoln, Mercury and Mazda, as well as the Premier Automotive Group (Volvo, Land Rover, Jaguar and Aston Martin). He was heavily involved in the Ford Fusion, Focus, Fiesta, Taurus, F-150 and Mustang, while also contributing to concept cars like the Atlas, Evos, 427, Forty-Nine, Shelby GR-1, Lincoln MKZ and the MKC.