1999 Ford F-250 4-door on 2040-cars

Auto blog

Ford recalls 591,177 vehicles in four separate campaigns

Ford is issuing recalls for a total of 591,177 vehicles worldwide, in four separate campaigns. The announcement comes just days after the discovery of door-latch problems in 390,000 of the automaker's cars. The largest of these new recalls covers 518,313 examples of the Ford Fusion and Lincoln MKZ from the 2013-2015 model years, plus the 2015 Edge. Of these, 487,301 of are in the US and 31,012 are in Canada. For vehicles in cold-weather areas, the bolts that hold the steering gear motor can corrode and fracture. If this happens, it could cause the power steering to fail, but manual control would be retained. There are no reported accidents or injuries from this problem. To fix things, dealers will replace the bolts and seal them. The next campaign covers 50,157 examples of the 2014 Focus, Edge, Escape, and Transit Connect, plus the Fiesta from 2014 and 2015. Of these, 45,505 are in the US, 4,618 in Canada, and 34 in Mexico. All of them exhibit a problem with the fuel pump where the nickel plating can cause the part to seize and the engine to stall, if this occurs. (All of which sounds like recent problems with Nissan and BMW models.) According to Ford, there is one allegation of an accident from this problem. Dealers will replace the fuel delivery module to fix the problem. Ford is also recalling 22,616 units of the 2015 Lincoln MKZ because when the headlights are on, the parking lamps are brighter than they are allowed to be. The light could affect the vision of other drivers. This campaign includes 21,435 of them in the US, 1,066 in Canada and 115 in Mexico. There are no accidents or injuries from the issue, but Ford is updating the software to dim the lights on these sedans. Finally, Ford has a safety campaign for 91 examples of the 2015 F-150 because an underbody heat shield might not be properly installed or not present at all, which can be a fire risk. There are no reports of any actual accidents or fires, though. The affected pickups will have the parts replaced or added, as necessary after a dealer inspection. To see the specific build dates for the models affected by each of these campaigns, you can read about them in the press release below. Related Video: FORD ISSUES FOUR SAFETY RECALLS IN NORTH AMERICA Ford Motor Company is issuing four safety recalls in North America. One accident and no injuries are attributed to these conditions.

Foreign automakers pay from $38 to $65 per hour to non-union workers

As leaders for the United Auto Workers gather in Detroit for their Special Convention on Collective Bargaining to work out the negotiating stance for this year's new labor agreements with the Detroit 3 automakers, what they most want to do is figure out how to eliminate the two-tier wage scale. However, the lower Tier 2 wage has allowed the domestic automakers to reduce their labor costs, hire more workers, and compete better with their import competition. As it stands, per-hour labor rates including benefits are $58 at General Motors, $57 at Ford, and $48 at Fiat-Chrysler – a reflection of FCA's much greater number of Tier 2 workers. The Center for Automotive Research released a study of labor rates (including benefits) that put numbers to what the imports pay: Mercedes-Benz pays the most, at an average of $65 per hour, Volkswagen pays the least, at $38 per hour, and BMW is just a hair above that at $39 per hour. Among the Detroit competitors, Honda workers earn an average of $49 per hour, at Toyota it's $48 per hour, Nissan is $42 per hour, and Hyundai-Kia pays $41 per hour. The lower import wages are aided by their greater use of temporary workers compared to the domestics. Automotive News says the ten-dollar gap between those foreign camakers and the domestics turns out to about an extra $250 per car in labor, which adds up quickly when you're pumping out many millions of cars. That $250-per-car number is one that, come negotiating time, the Detroit 3 will want to reduce, as the UAW is trying to raise both Tier 1 and Tier 2 wages. Another wrinkle is that the domestic carmakers are considering the wide adoption of a third wage level lower than Tier 2. Some workers who do minor tasks like assembling parts trays kits and battery packs already make less than Tier 2, but the UAW will be quite wary about cementing yet another wage scale at the bottom of the system while it's trying to fight a bigger battle at the top. News Source: Automotive News - sub. req., BloombergImage Credit: AP Photo/Erik Schelzig Earnings/Financials UAW/Unions BMW Chevrolet Fiat Ford GM Honda Hyundai Kia Mercedes-Benz Nissan Toyota Volkswagen labor wages collective bargaining labor costs

Ford's Farley will challenge dealers to cut EV cost to customers by $2,000

DETROIT — Ford Motor Co Chief Executive Jim Farley will go to Las Vegas next week to roll the dice on a strategy to convince dealers to cut as much as $2,000 from the cost of delivering an electric vehicle to a customer. Ford has told dealers that one key topic for the meetings will be a discussion of new agreements that would govern how dealers sell Ford's expanding lineup of electric vehicles. Farley told analysts in July that Ford needs to cut $2,000 a vehicle out of selling and distribution costs to be competitive with Tesla Inc and other electric vehicle startups that sell directly to consumers without franchised dealers. About a third of those savings could come from what Farley called a "low inventory model," where customers order a vehicle and Ford ships it to the customer, rather than stocking vehicles on dealer lots for weeks or months. "We think that's about -- worth maybe $600, $700 in our system," Farley told analysts. Tesla can also adjust prices rapidly on its website, and keep most of the gain from a price increase. Ford declined to comment other than to say “we are excited to meet next week with our North America dealers to grow and win together.” Dealers said they expect Ford to outline minimum investments for charging stations and other equipment to support electric vehicle customers. A key question will be how quickly dealers will be required to install chargers, which dealers said can cost as much as $500,000. "The manufacturers so far have let us scale into it and I think Ford will hopefully do the same thing. You just can't say, 'Listen, we're going to sell 2 million electric cars five years from now and we expect you to put in five superchargers,'" said Rhett Ricart, owner of Ricart Ford, a large dealership in Columbus, Ohio. Tesla's success at selling electric vehicles without franchised dealers is putting pressure on all established automakers to overhaul their retail networks. A shift by Ford to a Tesla-style build to order system could come with caps on the profit margins dealers can earn on a new vehicle sale, some dealers said. "I see dealer margins still being very competitive, but they are going to shift," Farley said in July. Ford intends to put more emphasis on selling products and services after the initial vehicle sale, he said. Dealers said state franchise laws could give dealers leverage to resist efforts by Ford to set fixed prices or fixed fees for delivering electric vehicles.