2007 Ford F-150 King Ranch Crew Cab Pickup 4-door 5.4l on 2040-cars

Auto blog

NHTSA investigating 725k Ford, Mercury vehicles for stalling issue

Owners of Ford Escape, Mercury Mariner, Ford Fusion and Mercury Milan models, listen up. According to a report on Automotive News, the National Highway Traffic Safety Administration has opened an investigation into these four vehicles totaling an estimated 725,000 units. The investigation appears to center around a malfunctioning throttle body on non-hybrid models of the 2005-2012 Escape and 2011-2012 Fusion. With Mercury dying off after the 2011 model year, this probe will also apply to the 2005 through 2011 Mariner and the 2011 Milan. There has been some discussion around the Escape stalling issue for some time now, but this investigation appears to be larger in scope than before.
Though not a recall yet, NHTSA's Office of Defects Investigation (ODI) has received 123 complaints of stalling or surging vehicles, while Ford itself has logged 1,472 complaints. The investigation report, which is posted below, seems to indicate that a faulty circuit board for the throttle body could cause the vehicle to go into limp mode, which, according to NHTSA, could cause complaints of both stalling and surging.

NHTSA will investigate some Ford Fusion, Lincoln MKZ models for power steering issue

The National Highway Traffic Safety Administration is opening an investigation into the 2010-2012 Ford Fusion, Fusion Hybrid and Lincoln MKZ, the 2012 MKZ Hybrid and 2011 Mercury Milan because the agency has hundreds of complaints of electric power steering failure in these models.
According to NHTSA's data, it has received 508 complaints of the power steering allegedly suddenly malfunctioning and resulting in increased effort to turn the wheel. In four incidents, these failures resulted in loss of control and crashes. According to the reports, in some cases a power steering warning message came on as the fault occurred, and other times the system restored itself by turning off and then restarting the vehicle. NHTSA said it has also received further field report data from Ford, but that information hasn't been publicly released yet.
For the moment, there isn't a recall for this failure on these models. NHTSA is just investigating them to "assess the scope, frequency and safety consequences of the alleged defect," and the agency says an estimated 938,000 vehicles could potentially be affected.

Ford profits soar as problems mount

Ford is doing well. It can't make enough examples of its new Fusion, it can barely make enough of the aging F-150, it's getting good brand rankings, people like its turnaround story, it's selling oodles of product and its quarterly profit numbers end in the word "billion." As other high-flying examples have demonstrated over the past few years, though, big numbers can come with problems that aren't exactly small.
Automotive News has published a good "nutshell" report of Ford's progress and problems. The Dearborn automaker's optimistic "general label rule" determination of gas mileage for the C-Max Hybrid has led to lawsuits, hybrid software updates, a downward revision of C-Max fuel economy and millions in rebates. AN notes the C-Max was the "worst-scoring model in this year's J.D. Power Initial Quality Study," but Ford will probably be happy that it managed not to be mentioned further in the study's results after last year's mediocre showing. Its MyTouch and SYNC systems, the bugbears sabotaging Ford's J.D. Power results, have also led to lawsuits, software updates, more software updates and a center console rethink. On top of that, the 1.6-liter EcoBoost in the 2013 Ford Escape that Ford called a "hero" was soon catching fire for three different reasons. And let's not even get into the troubled launch of the Lincoln MKZ.
The Automotive News piece notes that industry observers have been surprised at Ford's stumbles because everything has been looking so good. Nevertheless, there is still the issue of those billions in profits - the company is doing plenty of things, plural, right. Ford says it is tackling its problems, hiring engineers and instituting new quality control processes as part of its effort to find solutions. The test will be to see if in a year from now we begin the discussion of these issues with "Remember when Ford...", or "Problems continue at The Blue Oval."