Ford 4wd 4x4 Leather Nav Heated Seats Sunroof 3rd Row Third Row Dual Climate Tow on 2040-cars

Auto blog

IIHS updates overlap test: 2 SUVs get good marks, 9 fare poorly

Vehicles in crashes keep occupants safe by deforming around the cabin in a way that maintains cabin integrity. The Insurance Institute for Highway Safety's moderate overlap test, introduced in 1995, has been a huge contributor to improved safety for front-row passengers in a crash. IIHS President David Harkey said, "Thanks to automakers’ improvements, drivers in most vehicles are nearly 50% less likely to be killed in a frontal crash today than they were 25 years ago." In the 'unintentional side effects' column, crash safety has gotten worse for passengers in the back seats. When carmakers reengineered the front crash structure to protect the driver, more crash forces got distributed throughout the rear. IIHS research claims rear passengers have a 46% greater risk of fatal injury than front-row passengers, but back-seaters haven't benefited from the same upgrades in safety as the front row. The IIHS updated its moderate overlap test to address the issue, putting 15 vehicles through the new regime. Two earned good ratings — the 2023 Ford Escape and the 2021-2023 Volvo XC40 — one was acceptable, three were marginal and nine were rated poor. Every one of the crossovers sampled got good marks for all passengers in the original test. That test sees 40% of vehicle's width on the driver's side impacting an aluminum honeycomb barrier at 40 miles per hour. The updated test puts a crash dummy representing small woman or 12-year-old child in the seat behind the driver, the dummy's sensors and grease paint measuring the effectiveness of the restraints and the forces a human body would need to endure. To achieve a good rating, the "measurements must not exceed limits indicating excessive risk of injury to the head, neck, chest, abdomen or thigh." An institute engineer said, "In real-world crashes, chest injuries are the most common serious rear-seat injuries for adults." The sensors and video evidence showed back seat dummies in the Escape and XC40 endured minimal risk of injuries from excessive crash forces, from submarining under the seat belt, or from unwanted interaction with the side curtain airbag.   The Toyota RAV4 scored acceptable. The second-row dummy also endured minimal risk of injury to the chest and lower extremities. However, the lap belt slipped upward in a way that could increase abdominal injuries, and after the dummy's head dipped during crash impact, the head came back up between the rear curtain airbag and rear window.

NHTSA investigating 725k Ford, Mercury vehicles for stalling issue

Owners of Ford Escape, Mercury Mariner, Ford Fusion and Mercury Milan models, listen up. According to a report on Automotive News, the National Highway Traffic Safety Administration has opened an investigation into these four vehicles totaling an estimated 725,000 units. The investigation appears to center around a malfunctioning throttle body on non-hybrid models of the 2005-2012 Escape and 2011-2012 Fusion. With Mercury dying off after the 2011 model year, this probe will also apply to the 2005 through 2011 Mariner and the 2011 Milan. There has been some discussion around the Escape stalling issue for some time now, but this investigation appears to be larger in scope than before.
Though not a recall yet, NHTSA's Office of Defects Investigation (ODI) has received 123 complaints of stalling or surging vehicles, while Ford itself has logged 1,472 complaints. The investigation report, which is posted below, seems to indicate that a faulty circuit board for the throttle body could cause the vehicle to go into limp mode, which, according to NHTSA, could cause complaints of both stalling and surging.

Ford recalls nearly 1.3 million Fusions, Lincoln MKZs for brake hose leaks

Ford Motor is recalling nearly 1.3 million Fusion and Lincoln MKZ sedans built from the 2013 through 2018 model years because their front brake hoses may rupture and leak brake fluid, which could affect stopping ability and increase the risk of a crash. The company notified the National Highway and Transportation Safety Administration and says that in the event a leak occurs, the brake fluid warning light may illuminate on the instrument cluster behind the steering wheel. Dealers will replace the front brake hoses, free of charge, and notification letters to owners are to be mailed in mid-April. A second letter will be mailed once replacement parts are available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S12. The vehicles affected were manufactured between Feb. 3, 2012, and July 19, 2017. In mid-2020, Ford recalled 488,594 Ford Edge and Lincoln MKX SUVs for a similar problem regarding leaking brake lines.   Recalls Ford Lincoln Safety