2011 Ford Explorer Xlt,nav,navigation,dual Roofs,4x4,white on 2040-cars

Auto blog

Ford recalls 90,736 vehicles due to engine valve issue

Ford will recall 90,736 vehicles as engine intake valves in the vehicles may break while driving, the National Highway Traffic Safety Administration (NHTSA) said on Saturday. The recall impacts certain 2021-2022 Bronco, F-150, Edge, Explorer, Lincoln Nautilus, and Lincoln Aviator vehicles equipped with either a 2.7L or 3.0L Nano EcoBoost engine, the NHTSA said. According to documents posted by NHTSA and sourced from the automaker, "The engine intake valves may break while driving, which can result in engine failure and a loss of drive power." Following an investigation that started in January, 2022, Ford found 22 instances where "the engine intake valves fractured and fell into the combustion chamber of the engine causing catastrophic engine damage." The automaker's analysis continues: "Ford identified that the potential root cause of the failures was engine intake valve failure due to valves that exceeded the designed specification for hardness, were brittle, and more likely to fracture. Ford determined that this was due to the supplier’s grinding processes and the sensitivity of the intake valve material to grinding processes that were not within control specifications. The intake valve material was changed for vehicles produced after October 31, 2021." Fixing the problem will require replacement of the entire engine. "Dealers will inspect each vehicle to determine its cumulative number of engine cycles. For vehicles that do not meet the engine cycle threshold, dealers will accumulate high revolutions per minute (rpm) engine cycles per a service procedure. Engines will be replaced on vehicles that do not pass the engine cycle accumulation," Ford says.

1947 Chevy rat rod pickup leaves rubber and smoke in its wake

Cool comes in multiple flavors. One one hand, we have the sophisticated attraction of svelte design and the efficient use of power. Of course, on the other hand there is the allure of being the bad boy and going against the grain. That is part of the appeal of rat rods. Ideally, they are built without rules to an owner's specific tastes, and this widened and heavily modified 1947 Chevrolet pickup rod is a perfect example of that spirit.
Coming down the highway with a bent grille, rusted body and pouring smoke, it looks like the pickup from hell. It backs up the looks with some very impressive mechanicals too. Owner Troy Gubser says that the truck packs a Ford Power Stroke diesel with to 42 pounds of boost that runs out of 8-inch exhaust stacks at the back. He claims it managed 505 horsepower and 885 pound-feet of torque on the dyno. To harness all that power, this hot rod has a ZF five-speed manual gearbox with a ceramic clutch and short-throw shifter. Plus, it has cool little features like a doorbell on the tailgate that operates an air horn.
You might not expect a truck like this to actually be useful, but it has a fifth wheel coupling to haul an RV around drag races and car shows. The air suspension also probably keeps the ride fairly comfy when Gubser wants it to be. Scroll down to check out this beastly rat rod pickup and watch it engage in some diesel drag racing. Warning, there is some NSFW language.

FCA UConnect fiasco could set over-the-air updates back years

Since cars have become more software dependent, most major automakers have been inching toward enabling over-the-air updates to keep vehicle electronics, ranging from infotainment systems to safety features, current. But there are only two car companies — Fiat Chrysler and Ford —± currently doing OTA updates, and on a limited basis. GM CEO Mary Barra announced last summer that the automaker will launch a new EV architecture and infotainment system capable of over-the-air updates "before 2020." The one exception, per usual, is Tesla. Since the release of the Model S almost six years ago, the maverick EV automaker has made routine OTA software updates a core part of its vehicle platforms and value proposition, and has sent out updates for everything from adjusting ride height to enabling Autopilot, largely without incident. When I've asked automakers why they can't do the same thing, I've heard reasons ranging from running afoul of their dealers (and archiac regulation) to security concerns. Automakers like Ford and General Motors say they want to act like tech companies, which routinely send out OTA updates for a wide range of devices, but overall the car industry still moves at a very cautious snail's pace. And when automakers do try to move faster and take more risks — unlike with a smartphone update, which people bitch about but live with — the consequences can be significant when things go wrong. That's the case with Fiat Chrysler America and its recent public-relations nightmare when an OTA update went awry. The update went out at the end of last week for the Uconnect system in late-model vehicles, and it made head units go into a near continuous reboot, which caused owners to not only lose access to entertainment features, but also critical functions like emergency assistance. Almost immediately, owners took to Twitter to express outrage, and FCA was caught flatfooted. A tweet went out on Monday on the UconnectCares Twitter account that read, "Certain 2017 & 2018 Uconnect systems may experience a reboot every 45-60 seconds. Our Engineering teams are investigating the cause and working towards a resolution.