2003 Ford Explorer Eddie Bauer Sport Utility 4-door 4.0l on 2040-cars

Auto blog

Ford recalls EcoBoost-powered F-150 and SUVs for brake fluid leak

Ford is recalling approximately 280,000 trucks and SUVs equipped with its 3.5-liter EcoBoost engine to address a potential brake fluid leak. The recall covers the 2016-2017 Ford F-150, 2016-2017 Ford Expedition and the 2016-2017 Lincoln Navigator.  According to Ford's defect report, the issue stems from contamination in the brake fluid causing degradation or damage to the seals in the brake master cylinder, allowing fluid to escape. Ford says that braking performance is not immediately impacted by the leak, and owners may not realize there's a problem until a brake malfunction indicator appears in the cluster, accompanied by a chime.  "If the brake fluid in the reservoir is depleted to a predetermined level, the driver will receive an audible chime, message center alert, and red brake warning indicator in the instrument cluster," Ford said in its defect report to NHTSA. "If the driver continues to operate the vehicle, the drive may begin to experience a change in brake pedal travel and feel, and increased pedal effort." "If a loss of brake fluid is substantial enough to reduce brake function to the front wheels, full braking function would remain in the rear wheel circuit. However, reduced brake function in the front wheels can extend stopping distance, increasing the risk of a crash," Ford said.  The issue can be addressed with a replacement brake master cylinder, which Ford will install free of charge. Ford has already begun notifying dealers and will send notices to customers starting in April.  Recalls Ford Lincoln Ownership Safety Truck SUV

White House clears way for NHTSA to mandate vehicle black boxes

At present, over 90 percent of all new vehicles sold in the United States today are equipped with event data recorders, more commonly known as black boxes. If the National Highway Traffic Safety Administration gets its way, that already high figure will swell to a full 100 percent in short order.
Such automotive black boxes have been in existence since the 1990s, and all current Ford, General Motors, Mazda and Toyota vehicles are so equipped. NHTSA has been attempting to make these data recorders mandatory for automakers, and according to The Detroit News, the White House Office of Management Budget has just finished reviewing the proposal, clearing the way. Now NHTSA is expected to draft new legislation to make the boxes a requirement.
One problem with current black boxes is that there's no set of standards for automakers to follow when creating what bits of data are recorded, and for how long or in what format it is stored. In other words, one automaker's box is probably not compatible with its competitors.

NHTSA closes probes on Jeep Grand Cherokee, Ford Freestar and Mercury Monterey

The Detroit News reports the National Highway Traffic Safety Administration has officially closed its investigations into 2012 Jeep Grand Cherokee, 2004-2005 Ford Freestar and Mercury Monterey models. The separate probes found no issues that pose safety concerns. NHTSA began investigating certain Grand Cherokee SUVs over complaints that power steering hoses could detach during operation, thereby increasing the risk of a vehicle fire. Of the 24 reports of failure, none alleged smoke or fire in the engine bay, and Chrysler has since modified the power steering cooler assembly to reduce the likelihood of the failure.
Meanwhile, certain Ford Freestar and Mercury Monterey vehicles garnered a government probe after receiving complaints that the models were equipped with faulty scissor jacks. The agency had received six reports of the jacks failing or causing injuries, including one incident that resulted in a fatality. But NHTSA says the jack failure rate is similar to those found in other vehicles. In those six cases, the government agency found the jacks were being used for something other than changing a tire, and investigators could not determine whether the emergency brake was set or the rear tires were properly chocked.