1950 Ford Custom on 2040-cars

Auto blog

Major automakers urge Trump not to freeze fuel economy targets

WASHINGTON — Major automakers are telling the Trump administration they want to reach an agreement with California to avoid a legal battle over fuel efficiency standards, and they support continued increases in mileage standards through 2025. "We support standards that increase year over year that also are consistent with marketplace realities," Mitch Bainwol, chief executive of the Alliance of Automobile Manufacturers, a trade group representing major automakers, will tell a U.S. House of Representatives panel on Tuesday, according to written testimony released on Monday. The Trump administration is weighing how to revise fuel economy standards through at least the 2025 model year, and one option is to propose freezing the standards through 2026, effectively allowing automakers to delay investments in technology to cut greenhouse gas emissions from burning petroleum. The National Highway Traffic Safety Administration has not formally submitted its joint proposal with the Environmental Protection Agency to the White House Office of Management and Budget for review. Even so, last week, California and 16 other states sued to challenge the Trump administration's decision to revise U.S. vehicle rules. Auto industry executives have held meetings with the Trump administration for months and have urged the administration to try to reach a deal with California even as they support slowing the pace of reduction in carbon dioxide emissions that the Obama administration rules outlined. One automaker official said part of the message to President Donald Trump at a meeting on Friday will be to consider California like a foreign trade deal that needs to be renegotiated. Automakers want to urge him to get automakers a "better deal" — as opposed to potentially years of litigation between major states and federal regulators. On Friday, Trump is set to meet with the chief executives of General Motors, Ford, Fiat Chrysler and the top U.S. executives of at least five other major automakers, including Toyota, Volkswagen AG and Daimler AG, to talk about revisions to the vehicle rules. Senior EPA and Transportation Department officials will also attend. Environmental groups are eager to keep the rules in place, saying they will save consumers billions in fuel costs. A coalition of groups plans to stage a protest outside Ford's headquarters in Michigan.

Ford, Samsung shack up to bring regen braking to non-hybrid models [w/video]

Ford must be desperate to get itself ready for the beach this summer because it is really trying to get into shape. Shortly after unveiling the Lightweight Concept that cut the weight of a Fusion down to that of a Fiesta, it's now the rest of the line's turn for improvement. The company is wrapping up a 10-year research project aimed at developing next-gen automotive batteries to improve efficiency.
Ford claims that 70 percent of its lineup will have stop/start tech by 2017. The key to this massive proliferation is its new dual-battery system that combines a lithium-ion battery with a lead-acid one and regenerative braking. The setup works by harvesting braking energy and converting it to electricity. When the vehicle stops, the engine shuts off, but the Li-ion battery has enough juice to keep the accessories running. The engine starts up again as drivers take their foot off the brake. The layout would mean less wasted gas while idling. It's already available on Ford hybrids and is somewhat similar to the i-Eloop capacitor-based system from Mazda.
The bigger challenge is tuning the regenerative braking right. While hybrid drivers may be a little more adventurous, when it comes to getting a hang of regen braking, conventional buyers might not be so open-minded. The systems have a tendency to be a little grabby at first and then taper off at very low speeds. Ford needs to make sure it's just right to avoid turning off buyers.

NHTSA investigating 500k Ford and Mercury cars for lighting failures

The Ford Crown Victoria and Mercury Grand Marquis might be long gone as new models in showrooms, but the National Highway Traffic Safety Administration might check them out yet again for a potential problem. At the urging of North Carolina Consumers Council, the agency may open another investigation into the front lighting control module on vehicles from the 2003-2005 model years, and NHTSA estimates the issue could affect 517,945 vehicles. If the module stops working, it can cause a complete failure of all forward lighting, including the headlights. NHTSA previously investigated the issue in 2008 and 2009 but found no need for a recall, according to Bloomberg. Ford also extended the warranty on the part to 15 years or 250,000 miles. To prompt this new request, the North Carolina Consumers Council received a letter from a woman experiencing the module's failure. Upon further investigation, the council found 604 complaints of this problem on NHTSA's website, including seven crashes. Furthermore, the group has alleged that dealers told customers that the parts to perform the replacement weren't available, despite the extended warranty. According to the government agency, "A defect petition has been opened to evaluate the issue and make a grant or deny decision." Ford spokesperson Kelli Felker tells Autoblog via email, "We will cooperate with NHTSA, as we always do." You can read the council's complete letter to the Feds in PDF format, here. INVESTIGATION Subject : Loss of headlamp/exterior lighting Date Investigation Opened: APR 01, 2015 Date Investigation Closed: Open NHTSA Action Number: DP15002 Component(s): EXTERIOR LIGHTING All Products Associated with this Investigation Vehicle Make Model Model Year(s) FORD CROWN VICTORIA 2003-2005 MERCURY GRAND MARQUIS 2003-2005 Details Manufacturer: Ford Motor Company SUMMARY: The Office of Defects Investigation (ODI) has received a petition from the North Carolina Consumers Council, Inc. requesting a defect investigation of an alleged defect condition resulting in headlight and/or exterior lighting failure on 2003-2005 Ford Crown Victoria and Mercury Grand Marquis vehicles. The petition letter is attached for review. The petitioner alleges a defect in the lighting control module that powers the headlights which can result in the loss of vehicle headlights and/or all exterior lighting while driving. ODI has previously investigated this issue under PE08-066 which was closed without a defect finding.