1989 Ford Conversion Van Econoline 150 E on 2040-cars

Auto blog

Ford recalls 90,736 vehicles due to engine valve issue

Ford will recall 90,736 vehicles as engine intake valves in the vehicles may break while driving, the National Highway Traffic Safety Administration (NHTSA) said on Saturday. The recall impacts certain 2021-2022 Bronco, F-150, Edge, Explorer, Lincoln Nautilus, and Lincoln Aviator vehicles equipped with either a 2.7L or 3.0L Nano EcoBoost engine, the NHTSA said. According to documents posted by NHTSA and sourced from the automaker, "The engine intake valves may break while driving, which can result in engine failure and a loss of drive power." Following an investigation that started in January, 2022, Ford found 22 instances where "the engine intake valves fractured and fell into the combustion chamber of the engine causing catastrophic engine damage." The automaker's analysis continues: "Ford identified that the potential root cause of the failures was engine intake valve failure due to valves that exceeded the designed specification for hardness, were brittle, and more likely to fracture. Ford determined that this was due to the supplier’s grinding processes and the sensitivity of the intake valve material to grinding processes that were not within control specifications. The intake valve material was changed for vehicles produced after October 31, 2021." Fixing the problem will require replacement of the entire engine. "Dealers will inspect each vehicle to determine its cumulative number of engine cycles. For vehicles that do not meet the engine cycle threshold, dealers will accumulate high revolutions per minute (rpm) engine cycles per a service procedure. Engines will be replaced on vehicles that do not pass the engine cycle accumulation," Ford says.

Ford recalls 434k vehicles for several unrelated issues

It seems that the hard winter in much of the country has been as rough on some Fords as it has on many people. The Blue Oval is recalling roughly 434,000 vehicles in two separate recalls, and one of them partially caused by the salt used to melt the snow on roads.
The first recall covers 385,750 2001-2004 Escape models in the Midwest, Northeast and Canada because a subframe could rust and eventually fail. This is partially due to the road salt used in those areas, and about 349,000 of the affected vehicles are in the US. To remedy the problem, dealers are installing a reinforcement cross brace on the frame to strengthen them. There has been one crash caused by the failure but no injuries. According to The Detroit News, this is not the first rust-related recall for Ford. It estimates the company has repaired over two million vehicles since 2010 for problems on vehicles related to the iron oxide, including the rear wheel wells of the Freestar minivan.
The second recall covers 48,950 2013-2014 Ford Fusion, Escape, C-MAX and Lincoln MKZ models because welds in their seatbacks don't meet National Highway Traffic Safety Administration standards. The fault affects the front seats, and the sub-standard welds joining the setback to the recliner could increase the chance on injury. There have been no reported injuries or accidents caused by the problem, but there are 42,972 affected vehicles in the US and 4,744 in Canada.

2021 Ford Mustang Mach-E, Volvo XC40 Recharge score high in IIHS tests

New electric cars continue their streak of impressive crash test results. The two latest to go through Insurance Institute for Highway Safety testing are the 2021 Ford Mustang Mach-E and the 2021 Volvo XC40 Recharge. The former earned a Top Safety Pick award, and the latter picked up the Top Safety Pick+ commendation. Both vehicles got the top "Good" rating in every crash test, as well as the "Superior" rating for vehicle-to-vehicle collision prevention. They deviate when it comes to headlights and vehicle-to-pedestrian collision prevention. Because the Volvo has headlights rated "Good" on all trims, it got that extra "+" on its Top Safety Pick award. The Ford also has high-rated headlights available, but the standard units got the second lowest rating of "Marginal." As for the vehicle-to-pedestrian collision prevention, the Volvo received the second-highest "Advanced" rating, while the Ford was rated "Superior." Among the electric cars IIHS has tested, the Ford and Volvo continue a streak of high scores. The organization has evaluated the Audi E-Tron in both its body styles, as well as the Tesla Model 3, both of which get the Top Safety Pick+ rating. As a result of the XC40 Recharge's test score, Volvo pointed out that it is the only automaker whose entire lineup has received a Top Safety Pick+ rating. Related video: This content is hosted by a third party. To view it, please update your privacy preferences. Manage Settings.