2006 Chrysler Pacifica Base on 2040-cars

Auto blog

NHTSA closes book on Jeep 'trailer hitch' recall after all

After much debating and hand-wringing, the National Highway Traffic Safety Administration now says it has "no reservations" with Chrysler's plan to recall certain Jeep Liberty and Grand Cherokee models over concerns that their fuel tanks, which are located behind the rear axle, could rupture or leak in the event of a rear impact. The longstanding argument between the two entities saw Chrysler openly defy the Feds after a request to recall 2.7 million units back in June.
Chrysler's "voluntary campaign" will instead see it recall 1.56-million 1993-2004 model year Grand Cherokee SUVs, along with 2002-2007 Liberty models. Affected vehicles will get a trailer hitch installed free of charge, which Chrysler says will provide an additional degree of protection for the fuel tanks in the event of a crash. Jeeps with Mopar-branded hitches or hitches that were installed at the factory aren't affected by this recall.
Chrysler's argument throughout this battle has been that the Jeeps in question are no more susceptible to fires than comparable vehicles from the same time period, a position that NHTSA has seemingly arrived at as well. "Those vehicles performed at a rate similar to their peers. That is the keystone analysis as to whether something poses an unreasonable risk to safety," said outgoing NHTSA boss David Strickland during an interview with the The Associated Press.

Chrysler-Fiat quality chief out after another poor Consumer Reports showing

Fiat Chrysler has announced a management change following the company's woeful performance in the latest Consumer Reports Annual Auto Reliability Survey. Of the 28 brands surveyed, FCA's marques occupied the five the seven lowest scores, while Dodge, Ram, Jeep and Fiat were the four lowest scorers.
Doug Betts, FCA's 51-year-old head of quality "left the company to pursue other interests," which, considering the aforementioned paragraph, means he was sacked. According to Automotive News, Betts joined Chrysler in 2007, defecting from Nissan, and, insiders report, had a somewhat tumultuous relationship with new boss Sergio Marchionne.
His replacement is the newly promoted Matthew Lidane (shown at inset), who was formerly VP of systems and components. Lidane has been at Chrysler since 1987 and was previously chief engineer of the Jeep product team as well as the vehicle line boss for the compact US wide platform which (ironically) underpins two of FCA's lowest scoring vehicles, the Dodge Dart and Jeep Cherokee.

Chrysler extends fuel tank warranties on LX cars, NHTSA ends probe

The National Highway Traffic Safety Administration has ended its investigation of 153,817, 5.7-liter and 6.1-liter Hemi V8-powered 2006 Chrysler 300, Dodge Charger and Dodge Magnum models after reports of stalling. Chrysler has responded by granting a lifetime warranty on the fuel tanks for these vehicles.
NHTSA received 299 reports of engines stalling while the models were stopped or driving at low speeds, and began an investigation. The government agency found that the control valve shutoff float in the V8s' 19-gallon fuel tank could malfunction if the fuel had too high of an ethanol content. In many cases, the valve would break in the open position, allowing the tank to be overfilled, which would then cause the cars to stall. However, there were no accidents reported, and the vehicles could be restarted immediately.
There will not be a recall on these vehicles because, "the condition represents a low risk to motor vehicle safety and is adequately addressed by Chrysler's extended warranty," NHTSA said to The Detroit News.