2001 Chevrolet Suburban 1500 Ls Sport Utility 4-door 5.3l on 2040-cars

Auto blog

GM patent reveals new two-stage turbocharger

Modern turbochargers may be some of the best ever made, but performance is something that engineers are always trying to improve. According to GM Inside News, General Motors (GM) is hoping to alleviate some of the negative aspects of a two-stage turbocharger setup with a newly-patented design. The patent, that was filed on May 19, 2016, reveals a clever bypass system that allows the engine, a four-cylinder unit, to optimize both the low-pressure and high-pressure inlets for its respective functions. According to the filing, a conventional two-stage turbocharger setup is engineered to allow both turbines to operate simultaneously at low and mid engine speeds. At high engine speeds, only the low-pressure turbine works. The setup can't isolate either the low or high pressure side, which can impair low-end performance. GM's new two-stage turbocharger setup looks to eliminate this by linking the high-pressure turbo to the exhaust manifold through the high-pressure inlet duct. The low-pressure turbo is attached to the high-pressure turbo by a low-pressure inlet duct, which is linked to a connecting channel. A single actuator that is housed in the exhaust manifold creates a bypass that can opens the high-pressure inlet or close the connecting channel. Depending on what the engine load and speed is, the ECU guides the actuator—a single rotating spindle with discs corresponding to flanges on the high and low pressure sides—to isolate one of the two turbos. Isolating the turbos allow the respective inlets to be engineered for the best possible fluid dynamic performance. The setup should increase performance and decrease lag. There's no word on what car this setup will make an appearance on, but it will most likely be used in premium vehicles before trickling down to the rest of GM's vehicles. Related Video: News Source: GM Inside News, AutoGuide via GM Authority Cadillac Chevrolet GM Technology Sedan turbo patent engine turbocharging

Feds open investigation into Chevy Express, Ford Freestar rust issues

'Tis the season... for road salt. And with that, comes rust. And what does rust bring? Well, for Ford and General Motors, a National Highway Traffic Safety Administration investigation. According to The Detroit News, NHTSA is looking into potential recalls issues with Chevrolet Express vans and Ford Freestar minivans.
The feds have received five complaints that rust has caused leaking fuel filler pipes on 2003 Express vans. Separately, seven complaints have been filed over excessive rust in the rear wheel wells of 2004 Ford Freestar and Mercury Monterey minivans. The Freestar and Monterey went out of production in 2007. Neither issue has resulted in any crashes or injuries, according to the report.

GM takes heat for aborted Silverado riff on 'Boston Strong' at World Series

During game five of the World Series, Chevrolet was set to do a spot of marketing for the 2014 Silverado - fans at Busch Stadium in St. Louis would hold up placards that spelled out the words "Silverado Strong," a theme that Chevy has been promoting since the Silverado's launch with the song "Strong," by Will Hoge. The St. Louis promo was ultimately called off, though, over concerns that it'd be insensitive to the visiting Boston Red Sox. (You can see the image of what the stunt would have looked like above, courtesy of one timely Reddit user.)
Now, the Busch Stadium stunt might not have been a big deal, had the St. Louis Cardinals not been playing the Boston Red Sox. Following the tragic events in Boston during the marathon back in April, the phrase "Boston Strong" gained traction among the city's citizens, especially at sporting events. So, you can imagine that Chevy's appropriation of the phrase might not sit well with some fans.
The stunt was ultimately shelved after images of the signs went viral before the game, leading to a bit of a public backlash. Chevy spokesperson Michael Albano said of the promo that it was meant to show the brand's "commitment to baseball and its fans." But after the images went viral, the company "realized there was the possibility that we may offend some of the very fans we were trying to honor," Albano told Automotive News via email.