2015 Chevrolet Silverado 2500 Lt on 2040-cars

Auto blog

Chevy's 6.6-liter Duramax is pretty much all new

To say there's a heated battle in heavy-duty pickups is an understatement, with Chevrolet, Ford, and Ram constantly trading blows of increased torque, horsepower, and towing capacity. The latest salvo is the revised, more powerful turbo diesel 6.6-liter Duramax V8 in the 2017 Chevy Silverado. It has 910 pound-feet of torque, an increase of 145, putting it nearly level with the Ford Super Duty. Here's a closer look at where those gains come from. How exactly did Chevrolet add all that torque plus 48 horsepower? The automaker essentially took a fine-tooth comb to the entire engine. Chevy says it changed 90 percent of the V8, and the cumulative effect of those small changes adds up to big increases. As you might guess, the turbocharger is updated. The larger unit features electric actuation of the variable nozzle turbine (VNT), and what Chevy calls a double axle cartridge mechanism that separates the VNT moving parts from the housing. That helps with heat performance as well, with a claim that the exhaust side of the turbo can run continuously up to 1,436 degrees Fahrenheit. Helping that cause are six exhaust gaskets made of Inconel - an nickel alloy that contains chromium and iron – and upgraded stainless steel for the exhaust manifold. Despite having the same cast iron cylinder block, albeit with some minor enhancements, the engine has new cylinder heads, pistons, piston pins, connecting rods, and crankshaft, which have all been upgraded to handle 20 percent higher cylinder pressures. Alongside the increase in pressure, Chevrolet also increased the cylinder head's structure with a honeycomb design. The pattern features high-strength aluminum with dual layer water jackets that not only improve strength, but also optimize water flow for better cooling. For 2017, the cylinder head also benefits from integrated plenum that aids the engine in getting more air under heavy loads. The cylinder head isn't the only component to get a minor update, as the pistons have a larger diameter pin for improved oil flow. The same detailed improvements has been bestowed to the humble connecting rods (second in our hearts only to the inanimate carbon rod). The new design has the bolts oriented roughly 45-degrees to the rod instead of parallel. The angle split design, as it's called allows for easier passage through the cylinder.

Race Recap: Rolex 24 at Daytona was fast and feisty

Let the record show that victory at the 2015 Rolex 24 at Daytona went to the No. 02 Chip Ganassi Racing with Felix Sabates Target/Ford EcoBoost Riley DP driven by Verizon IndyCar drivers Scott Dixon and Tony Kanaan and NASCAR drivers Jamie McMurray and Kyle Larson. The winner did 740 laps to cover 2,634.3 miles in 24 hours and 57.667 seconds. That's a statement to this year's pace in spite of 18 cautions, two more than last year: the Michael Shank Racing Ligier got pole with a time of 1:39.194, slower than last year's pole time of 1:38.270; however, the winning car last year only did 695 laps. The fight for top honors was shaved to a four-car battle over the first third of the event. The No. 02 Ganassi car took the lead on the first lap, swapping it well into the night with the No. 01 Ganassi car, the No. 10 Wayne Taylor Racing Corvette DP, and the defending champion No. 5 Action Express Corvette DP, all of them staying within about 20 seconds of one another. The Action Express car had a fuel connector come loose and lost three laps getting towed back to the pits to have it reattached, but was back in the lead 18 hours in. The No. 01 Ganassi car dropped out with recurring clutch problems 22 hours in, retiring not long after. A race-within-the-race is where the concluding action happened, a seven minute, 30-second dash from the end of the last caution to the checkered flag. During the penultimate pit stops with an hour to go, Dixon was in second place followed Jordan Taylor in the Wayne Taylor Racing DP into the pits but beat him out, taking the lead. The Action Express car was in third. In the last pit stops of the race, Dixon gained even more time, getting a four-second advantage over Taylor. Then a full-course caution came out twenty minutes before the finish when a Prototype Challenge car hit the wall and caught fire, bunching up the field. That closed the pits, but the Wayne Taylor Racing car had to pit during that yellow because of a miscalculation of driver time. No driver can be behind the wheel for more than four hours in a six-hour period but Jordan Taylor was going to go over, so he came in to swap out for brother Ricky. That cost the team any chance of second place, since they took an additional drive-through penalty for entering closed pits. When the track went green again, Sebastien Bourdais in the Action Express car stayed all over Dixon for the final five laps but couldn't get around him.

Chevy will reveal the Bolt EV tomorrow at CES

The moment that electric vehicle consumers and green propulsion enthusiasts have been waiting for is almost upon us, as Chevy confirmed that it will unveil the production version of the 2017 Bolt EV Wednesday at CES in Las Vegas. Chevrolet previewed the Bolt in concept form at the Detroit Auto Show almost a year ago, proposing a compelling rival to the likes of the Nissan Leaf and BMW i3. We've expected the CES debut for awhile, and Chevy projects that the finished product will boast a range of more than 200 miles on a single charge. That's nearly double the Leaf's range, and significantly farther than the i3 will travel even with the Range Extender kicking in. All of that for under $30,000 after federal tax credits. Of course, Chevy's own Spark EV costs much less, but will only go 82 miles before it needs to plug in again. If you won't be in Vegas for the unveiling tomorrow, you can catch it on Facebook. It will be the first vehicle to debut on the new Facebook Live, featuring both a live video stream and a 360-degree interactive interior video. Once out on the market, the Bolt EV will join the Spark EV, Volt PHEV, and Malibu hybrid in a growing array of electrified vehicles from the American automaker, rivaling the likes of Toyota and Nissan for the most electrified vehicles in its lineup. Chevrolet Bolt EV Will Debut at CES 2016-01-05 DETROIT – Chevrolet will unveil the 2017 Bolt EV at the International Consumer Electronics Show (CES) in Las Vegas on Wednesday, Jan. 6, and be the first auto brand to work with Facebook to debut a vehicle using Facebook Live. With the addition of the Bolt EV to a lineup that includes the all-new 2016 Volt, 2016 Malibu Hybrid and Spark EV, Chevrolet will offer consumers more affordable, electrified vehicle options than any other major automotive brand – solidifying its position as the leader in electrification. "The Bolt EV truly embodies the ingenuity that is at the core of everything we do at Chevrolet," said Alan Batey, president of General Motors North America and head of Global Chevrolet. "The technologies and the engineering expertise behind the Bolt EV are tremendous examples of the kind of innovation we intend to offer our customers, across an array of products at a tremendous value – something only Chevrolet can deliver." Building on the electrification expertise established by the Volt, the Bolt EV is a game-changing, long-range electric vehicle.