1935 Chevy Pickup Truck (original) on 2040-cars

Auto blog

2016 Chevrolet Malibu Hybrid Quick Spin [w/video]

If a Chevy Volt is like a hybrid that prefers its electric motor, then the new Malibu hybrid is like a Volt you never have to plug in. That's partly because you can't plug it in, but more because the Volt and the gas-electric Malibu share a lot of major components. Since we happen to like the newly refined Volt, that's good news for the larger family sedan. The shared parts include the blended braking system, A/C compressor, the auxiliary power module, and most of the hybrid transaxle (what you might call a fancy electro-transmission). In the Malibu, the electric motors use neodymium magnets for efficiency and power, while the Volt has weaker ferrite magnets to reduce drag, and the Volt also gets an extra clutch to lock out the engine. The two use different batteries, with their size, power capabilities, and chemistry suited to the task for each vehicle. Unlike most of the midsized sedan leaders, the Malibu has never had a full hybrid option. For a few years in the last generation, Chevy offered the Malibu Eco with a version of GM's eAssist mild-hybrid system, which featured a small motor-generator in place of an alternator hooked up to a bigger battery that could harvest energy during deceleration and add some back in when you hit the throttle; it also brought engine stop-start functionality to save a little more fuel. But it saved only a little fuel, so eAssist was nixed in favor of a more efficient four-cylinder with a standalone stop-start system. Driving Notes Mode switches between gas and electric are just as smooth as in the Volt. No shudder or weirdness in the throttle. It drives as much like a gas-only car as any midsized hybrid does. The blended braking system is also noticeably well sorted. There's no deadness in the pedal, no touchiness, and no artificial, wooden feeling when you step through the regen portion of its travel. There's nothing abrupt or jarring about any of the experience, and the Malibu's baked-in quietness helps to deal with noise from the somewhat coarse 1.8-liter gas engine. Engine startup and shutdown are noisy from outside, but much less noticeable from within. The 2016 Malibu is larger yet lighter. The hybrid weighs about 125 pounds more than a comparably equipped 1.5T. You don't notice the extra weight, but there is some space eaten out of the trunk by the battery.

NHTSA investigating nearly 750,000 GM models over non-deploying airbags

Nearly 750,000 vehicles built by Chevrolet, GMC, and Cadillac are the subject of a National Highway Traffic Safety Administration (NHTSA) investigation due to non-deploying driver-side airbags. While the investigation is ongoing, the agency believes the issue is likely due to rust particles that form on the inflator's connection terminal interface. The list of nameplates included in the investigation includes Chevrolet's Silverado, Tahoe, and Suburban, GMC's Sierra, Yukon, and Yukon XL, plus Cadillac's Escalade, Escalade ESV, CT4, CT5, and XT4. All of the potentially affected vehicles are 2020 or 2021 models, according to a bulletin published on the NHTSA's website. Investigators launched the probe in April 2021 after 15 consumers reported airbag-related issues, including nine who said an airbag malfunction light appeared in the instrument cluster. More alarmingly, the NHTSA is aware of six accidents that caused significant damage to the car's front end yet didn't trigger the driver's airbag. It adds that there are no fatalities linked to the issue, but there are six crashes and eight injuries reportedly blamed on it. No evidence suggests this problem is related to the millions of potentially deadly Takata inflators recalled over the past few years. General Motors is aware of the defect. It sent a technical service bulletin (TSB) to its dealers in March 2021 to address the aforementioned warning light. The note explains the issue is due to "rust particles in the connection terminal interface of the driver's airbag inflator." The company hasn't issued a safety recall yet, however. Whether it will partially depends on the NHTSA's findings. It's currently looking into the scope and the severity of the problem, and it wants to understand its implications on driver safety. Investigators will decide whether General Motors needs to recall the 749,312 cars that are part of the probe when they close their investigation. General Motors has already spent a significant amount of money replacing defective airbag-related parts in its cars. In November 2020, it was ordered by the American government to recall nearly 6 million pickup trucks and SUVs equipped with potentially dangerous Takata airbag inflators. It repeatedly argued that testing proved the inflators were safe, and it petitioned the agency four times starting in 2016 to avoid a recall, which cost an estimated $1.2 billion (about a third of its net income in 2020).

Chevy ramps up development of Bolt EV

The Bolt is on the move, and Chevy confirmed Wednesday it is testing more than 50 prototypes as it prepares to launch the electric vehicle in 2017. We've already seen the photographic evidence in these spy shots, but Chevy released its own images and the above video as further proof that the EV remains on track toward production. Chevy revealed the Bolt as a concept in January at the Detroit Auto Show, promising a range of 200 miles on electricity with a price tag of about $30,000 after possible incentives. The prototypes are being hand-built and tested at the General Motors Proving Grounds in Milford, MI, and other global locations. "Effectively these are the bones of the car that's going to be the production Chevy Bolt," said Josh Tavel, the car's chief engineer. Chevy is testing the Bolt in all areas of vehicle competence, including ride and handling dynamics, cabin comfort, quietness, charging capability, and energy efficiency. More than 1,000 engineers are working on the program. "We really wanted to convey the notion that this is running fast. It's happening," said Pam Fletcher, GM's executive chief engineer of electrified vehicles. The Bolt will be built at GM's Orion Assembly plant north of Detroit and sold in all 50 states. It's part of the automaker's electric car blitz that includes the plugin hybrid Volt, the traditional (non-plugin) Malibu hybrid, and confirmation of plans to expand sales of the Spark EV to Canada and Maryland. Related Video: