** Hot Rod ** Pro Touring ** Biscayne ** on 2040-cars

Auto blog

New Takata problem results in recall of 414 GM vehicles

An airbag-inflator rupture discovered by Takata during testing has resulted in a new recall affecting 414 vehicles from General Motors, including 395 of them in the US. This latest campaign covers 2015 model-year examples of the Buick LaCrosse, Cadillac XTS, Chevrolet Camaro, Equinox, Malibu, and GMC Terrain. There are no reported breaks in any of these vehicles on the road, and the company estimates only one percent of them actually have the faulty parts. According to documents submitted to the National Highway Traffic Safety Administration (as a PDF), one side-airbag inflator failed a cold test at -40 Fahrenheit "releasing high pressure gas and propelling the separated components apart." The supplier told GM about the failure the next day. In these vehicles, the safety device might not only burst but the bag could inflate incorrectly, as well. GM and Takata say that a cause is not yet known, but they are "conducting an investigation." GM will begin notifying affected owners via overnight mail on Oct. 19. Dealers will replace the side airbag modules on all of the affected vehicles with new components outside of the suspect lot. All of the removed parts will also be collected for further study. Takata's faulty front airbag inflators have resulted in a serious scandal for the supplier. Initial figures indicated 34 million US vehicles are need of repair, though more recent figures have knocked that down to 23.4 million bad parts in 19.2 million automobiles. GM was already among the dozen automakers with models to fix, and some of its pickups were affected, along with the Saab 9-2X and Pontiac Vibe. GM Statement: General Motors is recalling 395 cars and crossovers in the U.S. because one of the front seat side air bags inflators may be defective. In the event of a deployment, the air bag's inflator may rupture and the air bag may not properly inflate. The rupture could cause metal fragments to strike the vehicle occupants, potentially resulting in serious injury or death. GM is unaware of any incidents involving vehicles with these components, which were part of a lot in which one inflator failed acceptance testing at the supplier. Dealers will replace the side air bag module or modules in affected vehicles. Including Canada, Mexico and exports, the total population of the recall is 414, GM estimates 1 percent of the recalled vehicles may have the defect.

Nissan Leaf, Chevy Volt have best sales month of 2015

Things are trending upwards for the two best-selling plug-in vehicles in the US. Both the Chevy Volt and the Nissan Leaf had their best sales month of 2015 in May, with the Volt selling 1,618 units and the Leaf moving 2,104. The upward swings come at an interesting time, with lots of excess first-gen Volts waiting for buyers and some buyers already ordering their second-gen Volts. So far in 2015, the Leaf has outsold the Volt 7,742 to 4,397. While 7,700 Leafs is respectable, it's nowhere near the numbers that Nissan will have to hit to reach the 50,000 annual sales that CEO Carlos Ghosn says is possible in the US. Still, the Leaf had its best sales month since December 2014 (when it sold 3,102 units) in May, but last month was still down 32.5 percent compared to May 2014. Despite the smaller overall number, May represents a big positive for Chevy, which has seen sluggish sales for the Volt for a long while now. The 1,618 Volts sold last month are only 3.9 percent lower than the 1,684 sold in May 2014 and May 2015 was the best month for Volt sales since August 2014. Perhaps salesmen are ready to make deals, what with thousands sitting around on dealer lots right now. The next-gen Volt is due this fall, and the order books (in California, at least) opened up this week. Like every month, our full wrap-up of green car sales in the US is coming soon (the VW e-Golf, for example, hit a best-ever high of 410 sales). Until then, feel free to discuss the Volt and Leaf sales figures in the Comments. Green Chevrolet Nissan Electric Hybrid ev sales hybrid sales

GM now finishing and shipping pickups it had parked for lack of chips

DETROIT — General Motors is more than halfway through shipping newly-assembled pickups that it had parked due to a shortage of semiconductor chips, a top executive at the No. 1 U.S. automaker said on Friday. "We've made great progress," Steve Carlisle, GM's North American chief executive said at the Reuters Events Automotive Summit. "We're a bit better than halfway through that at the moment and our goal would be to clear out our '21 model years by the end of the year. We'll have a bit of a tail of '22 model years into the new year but not for too long." The global chip shortage has forced automakers like GM to idle production or in some cases mostly build vehicles and then park them until the necessary chips can be installed, allowing those vehicles to be then shipped to dealers. Last month, GM Chief Financial Officer Paul Jacobson cautioned that GM's third-quarter wholesale deliveries could be down by 200,000 vehicles because of chip shortages. He did not break out what share of that was trucks. To expedite transportation of newly-built vehicles to dealers, Carlisle said GM bought a number of car haulers to deliver them from factories or distribution centers. The Detroit automaker has also allowed dealers to pick the vehicles up themselves in some locations. Carlisle said new vehicle inventories have shrunk to below 20 days in the United States due to the supply chain disruptions, but the company wants to get that back up to 30 to 45 days with some getting to 60 days depending on the product line. GM sees sales of gasoline-powered vehicles being steady over the decade and real growth opportunity in electric vehicles and software, with one not undermining the other, he said.