2006 Chevy Express 1 Ton Van on 2040-cars

Auto blog

How GM engineers are using diaper 'snow' to keep you warm

Testing how snow affects General Motors' vehicles isn't really a problem right now for the company's engineers, but in the dog days of summer the process isn't exactly easy. The only real option is for them to book time at the automaker's climatic wind tunnel. However, a flash of brilliance from an engineer allows snow to be simulated regardless of the temperature outside, and the discovery is all because of his daughter's wet diaper. The realization came to GM Thermal Systems engineer Nicholas Jahn while he was swimming with his daughter and noticed how her diaper ballooned in size in the water. He found out the substance that makes this possible is called sodium polyacrylate. When the material gets wet it grows and forms fluffy flakes that are a close imitation of snow. Best of all, the stuff can be prepared easily any time of the year, and it's reusable. The engineering team uses the material to test the effectiveness of the heating systems of GM's vehicles. They spread the sodium polyacrylate over the inlets at the base of the windshield to obstruct the airflow and then crank the heater. After some time, they can see how much is being sucked into the system and design more efficient systems in the future. See how the process works in the video above and read about the diaper discovery in GM's press release below. Diapers Change Chevy Cruze Winter Warm-up Time GM validation engineer uses diaper material "snow" to reduce frigid drives 2015-01-06 DETROIT – An item commonly found on an infant's changing table is helping General Motors' engineers simulate snow year round, ensuring heating systems in cars like the 2015 Chevrolet Cruze can quickly and efficiently warm its interior. Packed snow can prevent air from entering the inlet panel at the bottom of the windshield, obstructing the flow of air into the heating system and reducing the amount of air it can push out. This can lead to less efficient warming of the car's interior and windshield defrosting. "The last thing anyone wants to do when it's freezing cold out is scrape their windshield," said Nicholas Jahn, GM Vehicle Thermal Systems engineer. "The testing we perform on the Chevrolet Cruze with the diaper material allows us to maximize the car's heating capabilities." Ironically, Jahn stumbled upon his diaper-based testing method in the middle of summer. During a swim with his daughter, he noticed her diaper multiplied in size when it came into contact with water.

New Takata problem results in recall of 414 GM vehicles

An airbag-inflator rupture discovered by Takata during testing has resulted in a new recall affecting 414 vehicles from General Motors, including 395 of them in the US. This latest campaign covers 2015 model-year examples of the Buick LaCrosse, Cadillac XTS, Chevrolet Camaro, Equinox, Malibu, and GMC Terrain. There are no reported breaks in any of these vehicles on the road, and the company estimates only one percent of them actually have the faulty parts. According to documents submitted to the National Highway Traffic Safety Administration (as a PDF), one side-airbag inflator failed a cold test at -40 Fahrenheit "releasing high pressure gas and propelling the separated components apart." The supplier told GM about the failure the next day. In these vehicles, the safety device might not only burst but the bag could inflate incorrectly, as well. GM and Takata say that a cause is not yet known, but they are "conducting an investigation." GM will begin notifying affected owners via overnight mail on Oct. 19. Dealers will replace the side airbag modules on all of the affected vehicles with new components outside of the suspect lot. All of the removed parts will also be collected for further study. Takata's faulty front airbag inflators have resulted in a serious scandal for the supplier. Initial figures indicated 34 million US vehicles are need of repair, though more recent figures have knocked that down to 23.4 million bad parts in 19.2 million automobiles. GM was already among the dozen automakers with models to fix, and some of its pickups were affected, along with the Saab 9-2X and Pontiac Vibe. GM Statement: General Motors is recalling 395 cars and crossovers in the U.S. because one of the front seat side air bags inflators may be defective. In the event of a deployment, the air bag's inflator may rupture and the air bag may not properly inflate. The rupture could cause metal fragments to strike the vehicle occupants, potentially resulting in serious injury or death. GM is unaware of any incidents involving vehicles with these components, which were part of a lot in which one inflator failed acceptance testing at the supplier. Dealers will replace the side air bag module or modules in affected vehicles. Including Canada, Mexico and exports, the total population of the recall is 414, GM estimates 1 percent of the recalled vehicles may have the defect.

Burt Reynolds' movie re-creations fetch $379,500 in Vegas

The recent death of Hollywood legend and automotive enthusiast Burt Reynolds helped drive up the value of four of his former cars from the 1970s and '80s, which sold last weekend at Barrett-Jackson's Las Vegas auction for a combined $379,500. Reynolds, who died Sept. 6 at age 82, had offered three Pontiac Trans Ams — two of them re-creations of the cars he drove in "Smokey and the Bandit" and "Hooper" and the third from 1984 used to promote his United States Football League team, the Tampa Bay Bandits. The fourth was a 1978 Chevrolet R30 pickup truck, styled like the one featured in "Cannonball Run." The "Bandit" re-creation, a 1978 Pontiac Firebird Trans Am that Reynolds ordered to be as "movie-correct" as possible but featuring a custom-built 200-4R automatic transmission, sold for $192,500. The car features a freshly built Pontiac 400 cubic-inch V8 mated to a four-speed automatic and featuring all-new Butler Performance parts and air-conditioning components. Reynolds reportedly said this was his favorite car from his films, and it even came with an authentic movie-correct CB radio and CB antenna. The red retro-rocket "Hooper" '78 Firebird, with a 403 cubic-inch V8 and a three-speed automatic, hammered for $88,000. By comparison, a gold 1978 Trans Am also offered at the Las Vegas auction but not connected to Reynolds fetched $27,500. The 1987 Chevy R30 pickup was a re-creation of the Indy Hauler pace truck seen jumping over a moving freight train in "Cannonball Run." It hammered for $49,500. The fourth car never appeared in any of Reynolds' films but is instead the only surviving example of two Trans Ams used to promote the Tampa Bay Bandits of the now-defunct USFL, having been driven out onto the field by Reynolds and his late friend and co-star, Jerry Reed, during opening day one season. It also sold for $49,500. At the Barrett-Jackson Scottsdale Auction in 2016, Reynolds accompanied a 1977 Trans Am used to promote "Bandit" onto the auction block. That car sold for $550,000. Related Video: Featured Gallery Burt Reynolds 2018 Barrett-Jackson Las Vegas Auction Image Credit: Barrett-Jackson Celebrities Chevrolet Pontiac Truck Coupe Performance celebrity pontiac trans am pontiac firebird burt reynolds