2002 Chevy Express Passenger Van on 2040-cars

Auto blog

2016 Chevy Volt arrives with 50-mile EV range, 41 mpg [w/ video]

Let's start with the numbers. The 2016 Chevy Volt will have an all-electric range of 50 miles from a new, 18.4-kWh lithium battery. It will get 41 miles per gallon (combined) once the battery runs dry and have 102 MPGe. Oh, and it has five seats, sort of. To compare, today's four-seat 2015 Volt has a 38-mile range from a 17.1-kWh battery in a powertrain that offers 37 mpg and 98 MPGe. So, across the board, there are notable improvements. Now that that's out of the way, let's talk story. General Motors will unveil the new Volt at the Detroit Auto Show later today, but it's been talking about how this new version – the first major plug-in hybrid vehicle to get a serious redo in the modern era – was crafted with reams and reams of data from first-gen Volt customers. At a preview event for journalists last week, GM executive chief engineer Pam Fletcher told Autoblog that these owners "gave us the recipe" to make the second-gen model. At the top of the request list was more range (check), more "fun-to-drive" behavior (check?) and a smoother and quieter experience (we'll assume a check here, given that the new 1.5-liter four-cylinder – the first North American application of this new engine family – should offer more power with less noise than the previous 1.4-liter, four-cylinder powerplant). Other customer-driven changes in the new Volt include a different place to store the charging cable (in the side of the trunk instead of under the load floor) and a new brake system with improved blended regenerative braking feel as well as driver-selectable regen levels. The requested 50-mile range comes from a new, lighter battery that has increased capacity from fewer cells (192 vs. 288) and a simplified control architecture. Along with the new battery, the electric drive unit is a two-motor deal that is up to 12 percent more efficient and 100 pounds lighter, while also being "tremendously smaller," notes Fletcher. It offers 294 pound-feet of torque and a maximum 149 horsepower of "motoring power" delivered to the wheels. GM says it has worked hard to reduced the amount of rare earth materials in these motors, and one of them doesn't use any at all. The new powertrain offers improved acceleration times, as well. The 2016 Volt can go from 0 to 60 miles per hour in 8.4 seconds, a seven-percent improvement, while the 0-30 mph time has been improved by 19 percent, down to 2.6 seconds. The new Volt is more conventional looking, but certainly not completely ordinary.

Chevy Volt 'acceptable,' Nissan Leaf 'poor' in new IIHS safety tests

Ford C-Max Hybrid also scored "acceptable" rating. With US Nissan Leaf sales up almost 30 percent during the first half of the year, the only thing that might be able to stop the battery-electric vehicle is a good, stiff barrier. Unfortunately, thing's aren't always pretty when that happens in the real world, according to new tests from the Insurance Institute for Highway Safety (IIHS). Things with the Chevrolet Volt extended-range plug-in are a little bit rosier, though. The two plug-in vehicles were part of a batch of a dozen vehicles that just went through the IIHS's "small overlap" test, in which the driver's side front corner of the vehicle is crashed into a rigid barrier at 40 miles per hour. Out of the dozen, only the Mini Cooper Countryman was given a "good" rating. Five vehicles, including the Volt and the Ford C-Max Hybrid, were rated "acceptable," two were "marginal" and two, including the Leaf, were "poor." Plug-in vehicles are unique in the crash-test context because of their relatively large battery sizes. In the Volt's case, the driver had a "low risk" of injury, said the IIHS. But the Leaf's crash substantially pushed back the instrument panel and steering column, creating a scenario where the driver was "likely" to sustain leg injuries. The batteries in both the Leaf and the Volt passed safety tests specifically targeted at things like thermo and electrical properties and overall integrity. "Nissan is proud of the Leaf's 'Good' rating in all other IIHS tests, a 4-star NCAP rating from NHTSA and its IIHS Top Safety Pick rating in all previous years since the car's release," the company said in an e-mail sent to AutoblogGreen. "As for the performance of the 2014 Leaf in the 'small overlap frontal test,' Nissan will continue to review these and other results from the IIHS 'small overlap frontal test' as we seek opportunities for improvement." Check out the IIHS's press release and small car crash-test video footage below. Range of ratings: Small car ratings run the gamut in challenging small overlap front test The Mini Cooper Countryman is the only small car to earn a good rating among the latest group of 12 cars subjected to the Institute's small overlap front crash test. Two electric models and a hybrid also are in the mix, with varied results. The electric-powered Chevrolet Volt (with a gasoline engine "range extender") earns an acceptable rating, while its battery-electric rival, the Nissan Leaf, earns a poor rating.

NHTSA closes book on Ford, GM probes of 600,000 vehicles

US safety regulators have closed a pair of investigations into some 500,000 Ford Crown Victoria, Mercury Grand Marquis and Marauder sedans built between 2004 to 2007, and 100,000 Chevrolet Impala models from 2014. The Ford investigation focused on rusting heat shields, which may become dislodged and jam the steering, according to Reuters. The National Highway Traffic Safety Administration found that this happened very rarely. In fact, of the ten incidents filed with the government safety watchdog, six came from a single police department, which evidently had some sort of problem with its reporting. As for the Impala, the NHTSA investigators attributed two incidences of "unintended autonomous braking" to user error. In both cases, the vehicles were involved in rear-end collisions. According to GM investigators, it's believed that drivers accidentally activated the electric parking brake, causing the collisions. The vehicles in question were rental cars. Featured Gallery Ford Crown Victoria Related Gallery 2014 Chevrolet Impala View 10 Photos News Source: ReutersImage Credit: Ford, Chevrolet Government/Legal Chevrolet Ford Safety Sedan ford crown victoria mercury grand marquis