2009 Chevrolet Equinox Lt on 2040-cars

Auto blog

NHTSA upgrades probe into 1.7 million GM vehicles over wiper failures

WASHINGTON — The U.S. National Highway Traffic Safety Administration (NHTSA) said Tuesday it is upgrading an investigation into 1.7 million General Motors vehicles for windshield wiper failures. The auto safety agency opened the probe in November 2018 to see if GM needed to expand a 2016 recall of 2013 model year Chevrolet Equinox and GMC Terrain SUVs to cover additional vehicles. The engineering analysis probe covers 2010-2012 and 2014-2016 Equinox and Terrain vehicles. NHTSA could demand a recall after it completes the probe. NHTSA said it has reviewed 1,900 complaints and reports related to the issue in the 1.7 million vehicles. NHTSA said it has seen elevated failure rates in the 1.7 million vehicles, even though GM said the recalled vehicles have "double the warranty rate and five times the complaint rate." GM said it will "fully cooperate to support their investigation. We do not believe these windshield washer systems are defective." The wiper failures that prompted the 2016 recall were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the ball joint. GM said it was installing an improved windshield wiper motor and transmission assembly and relocating a drain hole at the base of the windshield. Related Video:

GM Ultium tech can scavenge heat from everywhere, even you

GM likes to give us tidbits about its Ultium platform from time to time, and today it’s telling us about the platformÂ’s ability to capture waste heat from the propulsion system. In addition to capturing from the propulsion system, it can also capture humidity from both inside and outside the vehicle and even from passengersÂ’ body heat. Yes, you, your family and/or your friends are a usable heat source as far as GM EVs are concerned. It then deploys the heat in an advantageous way. If at this point, youÂ’re screaming, "Heat pump!" youÂ’d be right. WeÂ’re talking about an elaborate heat pump system that GM is using for its Ultium-based vehicles. Every Ultium-based GM vehicle gets this system that is covered by 11 patents and four publications. The waste heat it collects is used in a number of ways, but its primary use is to heat the cabin quickly and efficiently. GM claims it can heat the cabin of its Ultium-based vehicles quicker than vehicles with traditional internal combustion engines. Plus, when put to use, GM claims that using the heat pump provides its EVs with up to 10% more range than theyÂ’d have without. Beyond heating the cabin, the heat pump is capable of putting waste heat to use by preheating the battery prior to charging so that you can charge quicker. The system can even cool the propulsion system in preparation for Watts to Freedom (WTF) launch control starts. GM says this was vital in helping the Hummer EV achieve its bonkers 0-60 mph time of about 3 seconds. “Having a ground-up EV architecture gives us the freedom to build in standard features like UltiumÂ’s energy recovery capabilities,” said Doug Parks, GM executive VP of global product development, purchasing and supply chain. “This helps us squeeze more efficiency, performance and overall customer benefit out of our EVs.” GM says itÂ’s been developing heat pump technology since the EV1 and its heat pump. This is the modern evolution of that technology, and GM says itÂ’s going to be implemented in every Ultium-based vehicle as a standard feature. Related video: Green Cadillac Chevrolet GM GMC Technology Electric Future Vehicles

Recharge Wrap-up: BMW cars to share i tech, Jordan to build solar EV charging network

Jordan is looking to promote EVs and build a solar charging network. The country is waiving import tariffs on electric cars, and is spending $120 million on solar chargers. It plans to build 3,000 charging stations, along with 30 MW of solar power. Some chargers will be powered by solar canopies, while others will get electricity from nearby solar farms. Jordan's solar plan should also help to lessen the amount of energy it needs to import from nearby countries. Read more from Navigant Research, or at Green Car Reports. BMW's mainstream cars will benefit from technology borrowed from the i3 and i8, according to BMW sales head Ian Robertson. In an interview with Automotive News, Robertson said that next-generation cars will use carbon fiber more extensively, and that more cars will get plug-in technology. He said that about half of i3 buyers opt for the range extender and added that it is incorrect to refer to a range-extended electric vehicle as a plug-in hybrid. Read more at Automotive News. The ethanol market should remain healthy despite falling oil prices. While cheap oil could drive down ethanol prices, demand still remains due to the federal biofuels standard. Additionally, ethanol producers may find it cheaper to ship their products as domestic oil production drops and railroad shipping opens up. Ethanol byproducts like distillers grains continue to sell, and foreign demand continues as other countries impose their own renewable fuel standards. Read more at Yahoo News. Via Motors will launch the production of an electric Chevrolet Silverado. The company will convert the pickups into range-extended EVs at its assembly line in Mexico, near GM's Silverado plant. Via has the capacity to produce 10,000 vehicles per year at its Mexico facility. Via Motors Chairman (and former GM Vice Chairman during the early days of the Chevrolet Volt project) Bob Lutz wants to help make EVs mainstream in America, and believes that requires electrifying pickups and SUVs. Read more in the press release below. Bob Lutz to Announce Production Launch of the Electrified Chevy Silverado BY VIA Motors Media access to Bob Lutz, former Vice-Chairman of General Motors and father of the Chevy Volt Bob Lutz is now Chairman of VIA Motors who builds the "Volt Style" extended range electric drive system for the Silverado, the Express Van and is working on the SUV's (Tahoe, Suburban) 5 years in development. Now production Launch and Consumer Sales in 2015.