1988 35th Anniversary Corvette #1102 on 2040-cars

Auto blog

The real costs of keeping a Chevy Volt on the road

The release of the new, 2016 Chevy Volt is sure to bring a surge of used electric vehicles to the market as early adopters trade their older models in. Many of these cars are selling for a fraction of their original price, thanks in part to federal and state incentives that lowered the initial cost to the first owner, which opens these cars up to a whole new class of consumers. While the prices are getting attractive, potential buyers are still hesitant to buy a used EV due to uncertainty about service and repair costs, but there may be some good news on the horizon. The Chevy Volt comes with a battery warranty that is good for at least 8 years and 100,000 miles, but many of the Volts popping up on the market have passed that 100,000-mile mark. The threat of needing a new battery can be a deterrent, especially with some dealers quoting prices as high as $34,000 for a full "drive motor battery replacement." That sum is more than the MSRP of a 2016 model. Some of the fear of EV maintenance and repair comes from the mystery of the individual pieces that make up the drivetrain and charging system. If we take a look at the Volt in terms of analogs to a traditional internal-combustion vehicle, the outlook becomes a little more friendly. The Volt battery pack consists of three lithium-ion modules in a T-shaped arrangement, each of which can be serviced individually. Module 1 is made up of 90 cells and corresponds to GM part number 22954462, which retails for $3,258.33; module 2 is made up of 72 cells and corresponds to GM part number 22954463, which retails for $2,930.00; lastly, module 3 is made up of 125 cells and corresponds to GM part number 22954464, and retails for $4,933.33. These part numbers have been added to the dealer order systems but have not shown up in the distribution centers at this time. Although all three of the modules add up to a fairly large $11,121.66 total and are still on hold for dealer ordering, the good news is that in most cases these battery cell modules do not need to be replaced. There are many other individual pieces mounted on the battery pack that are serviceable, such as the Battery Energy Control Modules (BECM) and the Battery Interface Control Modules (BICM). These modules control and monitor the battery packs and charging system and have been known to fail while the lithium-ion battery cells are not at fault. Some have been replaced under warranty, but if you are stuck buying one they run about $255 a piece for the part.

New Takata problem results in recall of 414 GM vehicles

An airbag-inflator rupture discovered by Takata during testing has resulted in a new recall affecting 414 vehicles from General Motors, including 395 of them in the US. This latest campaign covers 2015 model-year examples of the Buick LaCrosse, Cadillac XTS, Chevrolet Camaro, Equinox, Malibu, and GMC Terrain. There are no reported breaks in any of these vehicles on the road, and the company estimates only one percent of them actually have the faulty parts. According to documents submitted to the National Highway Traffic Safety Administration (as a PDF), one side-airbag inflator failed a cold test at -40 Fahrenheit "releasing high pressure gas and propelling the separated components apart." The supplier told GM about the failure the next day. In these vehicles, the safety device might not only burst but the bag could inflate incorrectly, as well. GM and Takata say that a cause is not yet known, but they are "conducting an investigation." GM will begin notifying affected owners via overnight mail on Oct. 19. Dealers will replace the side airbag modules on all of the affected vehicles with new components outside of the suspect lot. All of the removed parts will also be collected for further study. Takata's faulty front airbag inflators have resulted in a serious scandal for the supplier. Initial figures indicated 34 million US vehicles are need of repair, though more recent figures have knocked that down to 23.4 million bad parts in 19.2 million automobiles. GM was already among the dozen automakers with models to fix, and some of its pickups were affected, along with the Saab 9-2X and Pontiac Vibe. GM Statement: General Motors is recalling 395 cars and crossovers in the U.S. because one of the front seat side air bags inflators may be defective. In the event of a deployment, the air bag's inflator may rupture and the air bag may not properly inflate. The rupture could cause metal fragments to strike the vehicle occupants, potentially resulting in serious injury or death. GM is unaware of any incidents involving vehicles with these components, which were part of a lot in which one inflator failed acceptance testing at the supplier. Dealers will replace the side air bag module or modules in affected vehicles. Including Canada, Mexico and exports, the total population of the recall is 414, GM estimates 1 percent of the recalled vehicles may have the defect.

Recharge Wrap-up: 'Racing Extinction' Tesla, Wards praises 3 hybrids

The makers of Racing Extinction used a tricked out Tesla Model S for their movie. The artists and activists used the electric car as a platform to project images from nature in various cities to raise awareness about imperiled wildlife. In addition to a the high-powered projector, the Model S features a electroluminescent paint job that emits light to mimic creatures found in the wild, such as bioluminescent sea life. It also has a thermal imaging camera in the front of the car with a filter to view CO2 emissions. Check it out in the video above, and read more at Ecomento. WardsAuto has named the 2016 Hyundai Sonata Plug-In Hybrid's powertrain to its list of 10 Best Engines. As the first plug-in hybrid to make the list, WardsAuto World Editor-in-Chief Drew Winter praises Hyundai engineers for their "impeccable job blending fuel efficiency with refinement and daily usability." Wards notes the car's smooth transitions between electric and hybrid modes, and a well-connected six-speed automatic transmission. Other electrified vehicles to make the list are the 2016 Chevrolet Volt and 2016 Toyota Prius. Read more from Hyundai, at Green Car Reports. FEV's plug-in hybrid battery pack has gone into vehicle series production. The 10-kWh battery pack, developed by the German development services provider, offers an all-electric range of about 30 miles. FEV says its battery management algorithms are just as important as choosing the right battery hardware. "The core system for the battery development is our own mature battery management system (BMS), now in its third generation, that together with optimized algorithms allows a very reliable and stable control of the battery," says FEV's Dr. Michael Stapelbroek. Read more at Green Car Congress, or in the press release from FEV below. Hybrid Vehicle Goes Into Series Production FEV development competence consists of batteries, controls, as well as complete drive systems FEV has demonstrated competence in the development of alternative drive concepts for almost twenty years. Most recently, yet another plug-in hybrid vehicle has gone into series production with technology provided by the Aachen-based developer. In addition to using an innovative transmission concept which is based on a FEV patent, FEV also developed the battery technology of the plug-in hybrid vehicle to series production readiness.