1975 Chevrolet Corvette Stingray Coupe 2-door 5.7l-350 H.p. on 2040-cars

Auto blog

GM opens official investigation into C8 Corvette transmission leaks

In March 2020, a month after Chevrolet began customer deliveries of the 2020 C8 Corvette, a GM dealer technician created a Reddit thread about a leaking gearbox in a Corvette with 32 miles. That car hadn't even been sold yet. Since then, as a search of "C8 Corvette transmission leak" shows, it's been tales of woe for some owners. Something in the Tremec TR-9080 transaxle in the back of the mid-engined Corvette doesn't work as it should, the fault able to cause codes that the transmission needs service, or that the driver needs to shift to park. In some cases, the battery would die because of follow-on issues after the initial transmission code, that code preventing the car from powering down. As Autoevolution reports, GM filed paperwork with the National Highway Traffic Safety Administration in August to look into what's going on. Between forum threads and GM's investigation document, there are several issues mentioned. The most common appears to be the dual-clutch transmission leaking fluid due to gasket failures like the one suffered by one owner at 858 miles, and another for an owner currently enduring a second leaking transmission. The Midengined Corvette Forum reported that Chevy engineers redesigned the TR-9080 pan, fitting Corvettes with the new unit at some point in the 2021 model year. The original pan was stamped steel unit affixed to the engine with two studs and 13 bolts, plus "reinforcement plates." The updated pan is said to be a cast aluminum unit affixed with two studs and 17 bolts, omits the reinforcement plates, and gets a new machined new groove around its edge to seat the gasket seal. The GM paperwork now at the NHTSA mentions a P1789 code, and says one reason for it could be "debris on the park position sensor magnet causing an incorrect position reading to the TCM." This might be caused by another issue mentioned in forums, which is clogged transmission filters. GM gives instructions for returning transmission filters to the company, and a poster on one forum said the Corvette tech at the dealer where he bought his Corvette told him the automaker "requires every used transmission filter to be returned to GM."  Whatever's going on, the problems haven't stopped, and they go beyond the P1789 code. Over the weekend, a 2022 Corvette owner posted on Corvette Forums that he got a check engine light on his car after just 850 miles.

10 of 18 midsize SUVs earn 'good' IIHS side impact safety rating

It's not terribly surprising that midsize SUVs earned better safety ratings than small SUVs in the latest side-impact tests performed by the Insurance Institute for Highway Safety (IIHS). Just how much better they scored, on the other hand, certainly raises an eyebrow. Ten out of 18 midsize SUVs earned the highest rating of 'good' in the stringent new test, altered for vehicles starting with the 2020 model year with a heavier barrier (4,200 pounds) that moves at a higher speed (37 miles per hour) and is fitted with a hard honeycomb frontal structure. By way of contrast, just one out of of 20 small SUVs earned a 'good' score.  SUVs that receiving 'good' scores were the Ford Explorer, Infiniti QX60, Lincoln Aviator, Mazda CX-9, Nissan Pathfinder, Subaru Ascent, Toyota Highlander, Volkswagen Atlas, Volkswagen Atlas Cross Sport and Volkswagen ID.4. For EV fans, it's worth noting the ID.4 was the only electric vehicle included in the test. The Buick Enclave and Chevrolet Traverse scraped away with 'acceptable' ratings while the Honda Passport, Honda Pilot, Hyundai Palisade, Jeep Wrangler 4-door, Kia Telluride and Nissan Murano were deemed merely 'marginal' in the tough new test. Only two models — the Mazda CX-9 and Volkswagen ID.4 — earned a "Good" rating in every test category.  Interestingly, the Jeep Wrangler would have scored a 'good' rating if it were equipped with side airbags for the rear seating positions. It would likely be an engineering challenge to equip its removable top and/or doors with airbags, but the lack of that safety feature allowed the head of the rear passenger dummy to hit the vertical support of the top. Otherwise, the Wrangler scored good ratings across the board. The new Ford Bronco, which makes more allowances for side-impact safety, has not yet been tested.  The popular Hyundai Palisade and Kia Telluride SUVs stand out in the test with 'poor' ratings for driver pelvis injuries. The Nissan Murano, a vehicle last redesigned for the 2015 model year, was the only vehicle tested that received a 'poor' rating for its structure and safety cage. Videos of the tests of 12 of these 18 SUVs can be found on the IIHS' YouTube page. Related video: Green Buick Chevrolet Ford Honda Hyundai Infiniti Jeep Kia Mazda Nissan Subaru Toyota Volkswagen Safety Crossover SUV IIHS Insurance Institute for Highway Safety

GM shows off 'digital vehicle platform' enabling more in-car tech and OTA updates

It appears to have dropped the sobriquet "Global B," but General Motors' new electrical architecture has bowed in drawings and video. This is the "digital vehicle platform" GM president Mark Reuss spoke to Reuters about in 2015, saying it would move a great deal of a vehicle's computer work to the cloud and enable over-the-air updates. Reuss took the microphone for the debut, too, saying, "Our new digital vehicle platform and its eventual successors will underpin all our future innovations across a wide range of technological advancements, including EVs and expanded automated driving." The system will go into production later this year, appearing in dealerships first either on the 2020 Cadillac CT5 or the mid-engined 2020 Chevrolet Corvette. Yes, these are the same electronics cited for delaying the launch of the C8 Corvette over excessive draw, security and getting the more-than-100 computer modules to communicate seamlessly. When Car and Driver asked about that, GM replied with "No comment." Volkswagen's having the same issues with the Mk8 Golf right now, though, so GM isn't alone, and this will be the new normal among OEMs for a while. What's certifiable is that the new architecture is robust enough to handle 4.5 terabytes of data per hour, which is five times what GM's current wiring can handle. And thanks to Ethernet connections of 100 Mbps, 1 Gbs and 10 Gbs, communication within and without the vehicle happens much faster. The advances mean better screen resolutions, better battery management for hybrids and electric vehicles, the capability for over-the-air updates and "functionality upgrades throughout the lifespan of the vehicle." Cadillac's Super Cruise has already been lined up as a leading candidate for constant improvements in the driving assistance suite, a key part of GM's "vision for a world with zero crashes, zero emissions and zero congestion." And whenever GM decides to take the plunge, it will mean a 48-volt electrical system. More than 300 specialists worked on the digital platform, and security was a huge part of the task. We've already heard that GM consulted with Boeing and military contractors on how to prevent hacking. The carmaker has an internal Product Cybersecurity group that reached out to the research community, and created a "bug bounty" program to crowdsource uncovering any flaws.