*2005 Volkswagon Jetta (vw) 4dr Stylish Sedan (auto) 5cyl Loaded _ Dark Blue! * on 2040-cars

Auto blog

An inside look at VW's new California R&D center

Less than two months ago, the Volkswagen Group opened a new facility in Oxnard, California (about an hour's drive west of Los Angeles). The $27 million investment, touted as Test Center California (TCC), serves as a research and development lab testing emissions for all brands under Volkswagen's umbrella, including its newest member, Porsche. While still not fully operational, we toured the new 64,000-square-foot building last week and had a first-hand opportunity to see just how much work is involved testing engines and meeting increasingly stringent government emissions standards.
Replacing a similar facility established in 1990 in Westlake Village (about 20-minutes east of the new location), our guide explained how Oxnard was chosen for its temperate climate, varied regional terrain for test drives and low altitude. (The area is only a few feet above sea level - a critical parameter when instrument testing emissions.) The new facility is capable of analyzing hundreds of vehicles, prototypes and customer-owned vehicles, annually.
Most interesting to us was the huge stainless steel climate chamber, with a massive four-wheel dynamometer that allows VW to test running vehicles in both scorching desert and freezing climates without ever leaving the building (an Audi Q7 was running in place during our visit). We were also mesmerized by the countless storage tanks and intricate plumbing of chemicals, stored in both liquid and gas states, needed to perform the variety of tests. Lastly, we took a look at Bugatti's service center on the west coast, located completely within the new center. While there were no supercars on site, the facility is equipped with plenty of spare forged wheels (mounted with expensive Michelin PAX tires) and a Veyron-specific repair jig that allows the vehicle to be completely disassembled, if needed. It is a shame that the facility, which set off all of our automotive geek alerts, is closed to the public.

2014 Volkswagen Golf GTD is our favorite oil-burning GTI

The 2014 Volkswagen Golf GTD has officially bowed at the 2013 Geneva Motor Show. Engineers managed to squeeze an additional 14 horsepower and 22 pound-feet of torque out of the familiar 2.0-liter turbodiesel four-cylinder engine, nudging total output to 184 hp and 280 lb-ft for 2014. The figures are good enough to earn the GTD the honor of being the most powerful diesel Golf in Volkswagen history. A start/stop system helps improve efficiency over the previous generation with the new model consuming 56 miles per gallon on the EU cycle. That's up from the 2013 model's 46 mpg. A six-speed manual transmission is standard equipment, though a six-speed dual-clutch gearbox is also available.
The GTD also offers buyers a few aesthetic tweaks to help separate the hatch from its less potent siblings. Those include a more aggressive front fascia, special badges and 17-inch alloy wheels. Expect to find the GTD in one of three exterior colors, including Tornado Red, Black and Pure White. Check out the quick press release below for more details.

VW announces recall of 26,000 2014 models with 1.8T engines

Volkswagen has followed up on a stop-sale order from earlier this month, announcing a voluntarily recall of 26,400 vehicles that are powered by the brand's 1.8-liter, turbocharged four-cylinder engine. The new mill replaced the despised 2.5-liter five-cylinder in the Jetta, Passat, Beetle and Beetle Convertible last year. Weirdly, though, of the 26,452 units covered in the recall, only 1,655 are customer vehicles.
According to VW, the affected models were built between February 1 and April 6 of this year, and feature bad O-ring seals in the transmission oil cooler. Apparently, the faulty O-rings could cause a fluid leak, as they won't seal between the oil cooler and transmission. VW is blaming a material change from a supplier for the problem.
There have been no fires, injuries, accidents or fatalities relating to this issue, which VW will be fixing free of charge. Customers will need to report to dealers to have the O-rings replaced.