Legacy ^ Gt ^ Awd ^ Navigation ^ Auto ^ No Reserve on 2040-cars

Auto blog

Subaru mulling expanding Indiana plant for Forester, Impreza

Thanks to currency fluctuations and their impact on the bottom line, a growing number of Japanese automakers are starting to increase vehicle production in the US, and it appears Subaru could be the next to do so. According to Bloomberg, Subaru is looking into expanding production capacity at its Lafayette, Indiana assembly plant, which currently builds the Outback, Legacy and Tribeca as well as the Toyota Camry.
Subaru's Indiana plant currently has an annual maximum capacity of 310,000 units, but the automaker is expecting to far exceed that figure this year, with year-to-date sales of 299,788 units through November (not including Camry) - an increase of almost 30 percent over 2011. The report indicates that Subaru could expand the plant to add as many 50,000 additional units to the plant, likely in the form of either the Forester or Impreza.

US Army tests Subaru-powered hybrid truck

The military has been studying the implementation of alternative drivetrains for years, a tiny sampling of which includes the diesel-electric hybrid technical hauler and L-ATV from Oshkosh Defense and the Aggressor from Quantum Technologies. There was also ADA Technologies' work with ultracapitors, General Motors' focus on fuel cells and the roll out of electric motorcycles for Special Forces. In the Ultra Light Vehicle (ULV) prototype vehicle pictured above, we have the latest developments in the Department of Defense's hybrid interest combined with a need to develop a lightweight replacement for the AM General Humvee.
In 2010 the Office of the Secretary of Defense put the Army's Tank Automotive Research, Development, and Engineering Center (TARDEC) in charge of developing a personnel carrier that could "balance payload, performance and protection," and do so without exorbitant cost. Armored Humvees can weigh more than seven tons, and while the ULV is just under 14,000 pounds, the new vehicle can do a lot more with its weight.
The Subaru turbodiesel under the hood puts out 175 horsepower and 260 pound-feet of torque. That's not much for pulling 13,916 pounds, so it's assisted by two Remy 410HVH HT electric motors each capable of adding 268 continuous hp and 369 peak hp, along with 844 lb-ft of continuous torque or 1,221 ft-lbs at peak. They're only limited by the 14.2 kWh lithium-ion battery rated at 65 kW of continuous power and 180 kW of peak power, but still, TARDEC says the ULV can do 21 miles on electric power and on the flats has a combined range of 337 miles at 35 mph.

Next-gen Subaru WRX STI spotted at the N"urburgring

Subaru has been busy testing the next-generation WRX STI. Well, it may be the STI. The big wing out back lends some credence to that theory, but it could be that the basic WRX is getting new action in the back section. Time will tell.
In either case, spy photographers nabbed a few shots of the heavily camouflaged sedan running around the Nürburgring. Unfortunately, it looks as if Subaru has taken some of the sexy out of the WRX Concept we saw at the New York Auto Show, leaving this car looking more derivative of the current model than a revolution in design. The bold power bulge has disappeared from the vehicle's hood and the lower fascia looks far more demure than the the wild concept. Likewise, the muscular rear fenders have been toned down substantially.
The result is a car that looks more like a mildly warmed over version of the current model than a production version of the WRX Concept. Still, engineers and designers may have a long way to go before the finished product hits the market, so we'll reserve final judgement for now. After all, the early BRZ mules were nothing short of a travesty to look at, and we know how that turned out. Hope springs eternal.