2000 Jeep Wrangler Sahara Rock Crawler 4.0l on 2040-cars

Auto blog

Chrysler recalling 630k Jeep models worldwide

Despite its refusal to recall 2.7 million Jeep Grand Cherokee and Liberty models this week over a gas tank fire risk, Chrysler will be recalling 630,000 Jeep Compass (pictured), Patriot and Wrangler vehicles around the globe for a pair of entirely different reasons.
The affected Compass and Patriot models are all from the 2010 to 2012 model years - 254,000 in the United States, 45,400 in Canada and 109,000 elsewhere in the world. In these models, a software error may result in the late deployment of the side airbags and seatbelt tensioners. In the event of a crash, failure of these systems could result in more serious injuries for the vehicle's occupants.
Jeep's go-anywhere Wrangler also faces a separate recall due to power steering fluid lines that can possibly wear a hole in the transmission oil cooler line. According to Chrysler, the vehicles could then leak fluid, possibly damaging the transmissions. Roughly 221,100 Wrangler models are being recalled because of this issue, all of which are fitted with Jeep's 3.6-liter Pentastar V6 engine. In the US, 181,000 vehicles are affected, with an additional 18,400 in Canada and 21,700 additional units worldwide. A Chrysler spokesperson said that no crashes or injuries have been reported with either case, according to the Associated Press.

Dodge and Jeep recalling 895k SUVs for possibility of headliner fires

Dodge and Jeep are announcing recalls of a total of 895,000 Durango and Grand Cherokee models worldwide from the 2011 through 2014 model years. There's a possibility that the wiring in the sun visor can short circuit and cause a fire. It specifically affects vehicles built between January 5, 2010, and December 11, 2013, and there are approximately 651,000 of them in the US, 45,700 in Canada, 23,000 in Mexico and 175,000 outside of North America.
Screws that fasten the sunvisor to the headliner may pierce wires in the visor, if the part has been removed or serviced, potentially causing a fire risk. If the wires short circuit, they could overheat and potentially combust. The automakers report three injuries caused by this defect, and according to the investigation by the National Highway Traffic Safety Administration, "there may be a total of 52 unique fire incidents."
To fix the problem, Dodge and Jeep will inspect the vehicles for suspect wiring, and all of the models, whether damaged or not, will get a new sun visor spacer with a wire guide to stop the possibility of short circuits. According to the automakers' announcement, "this condition is not present in vehicles which have not had the headliner or vanity mirror serviced." They will notify affected owners, and repairs will begin in August.

NHTSA closes investigation into Jeep Liberty fires

The investigation that the National Highway Traffic Safety Administration opened into the Jeep Liberty in October 2013 has been closed. NHTSA received two (!) complaints about fires starting in the driver's door, thought to be caused by the master power window switch. The initial estimate was that 80,000 Libertys could be roped into a possible recall, but according to a report in the Detroit News the agency examined records for 425,000 Chrysler products that used the same window switch, including the Dodge Nitro and Chrysler Town & Country minivan.
After canvassing 265 warranty claims related to the master switches, NHTSA concluded that the rate of fires compared to the "large population of vehicles" was rather low, and that there was no trend pattern behind the few issues it did find. Perhaps with that, and the closure of the trailer hitch investigation, the Liberty can finally rest in peace.