Gmc: Suburban Lt on 2040-cars

Auto blog

GM recalling another 2.7 million vehicles in five separate campaigns

The recalls keep rolling in from General Motors, evidently keen to avoid repeating the mistakes of the ignition-switch debacle and clean house. This time they're all coming at once, with five separate recalls announced together covering approximately 2.7 million vehicles.
The largest of the five actions involves over 2.4 million units of the previous-generation Chevrolet Malibu and Malibu Maxx, Pontiac G6 and Saturn Aura in order to fix brake light wiring harness, which have been found to be susceptible to corrosion. The recall is separate from the 56k Aura sedans which GM recently recalled over faulty shift cables, not to mention the previous massive recall of 1.3 million vehicles - some of them the same models - but appears to have resulted from the National Highway Traffic Safety Administration investigation that started with the G6 almost a year ago.
The second-largest campaign involves the 2014 Chevy Malibu, specifically those fitted with GM's 2.5-liter engine and stop/start system, approximately 140,000 examples of which has been found to have problematic brakes. The issue does not appear to be connected to the recall of 8k Malibu and Buick LaCrosse sedans (also involving brake woes) which we reported upon last week. Four crashes have been reported in such models, but GM admits it's not yet clear if the problem was a contributing factor in the accidents.

GM recalling 54k Cadillac SRX, HD pickup models

There are more recalls to report General Motors, but these latest actions pertain to newer examples of the Cadillac SRX, Chevrolet Silverado HD and GMC Sierra HD. With so much scrutiny on the company's recall strategy, GM is under increasing pressure to call in defective models more quickly, and it appears to be doing so here.
Here in the US, the automaker is recalling 50,571 Cadillac SRX crossovers from the 2013 model year fitted with the 3.6-liter V6 because the transmission control module programming can cause a three- or four-second lag in acceleration at low speeds. The explanation filed with the National Highway Traffic Safety Administration states, "if the following sequence occurs within two seconds: during an upshift from first to second gear (8-10 mph), the driver then brakes the vehicle to less than 5 mph, and then accelerates again," the delay can occur. According to Automotive News, the recall effects 56,400 vehicles worldwide, and the company is not aware of any crashes caused by the problem. The fix consists of a transmission control module (TCM) reflash.
In a separate recall, GM is repairing 51 Chevrolet Silverado HD and GMC Sierra HD pickups from the 2015 model year in the US. In vehicles with diesel engines and dual fuel tanks, the nuts that connect the fuel pipe to each side of the transfer pump between the tanks may be improperly torqued, which could cause a fuel leak. Obviously, this could be a fire hazard. The remedy is simply tightening the hardware. According to GM spokesperson Alan Adler, there have been no fires actually caused by the potential leak. "Only 21 of the trucks are in customer possession and they can be fixed anytime because there are no parts involved. The others are being fixed at dealerships," Adler said in an email to Autoblog.

GM can't keep up with most popular pickup orders

With the market for pickup trucks at its best since before the recession, General Motors can't afford any hiccups with the launch of its new 2014 Chevrolet Silverado and GMC Sierra twins, but it sounds like the popularity of V8-powered trucks is causing some supply-chain issues. Bloomberg reports that GM is experiencing a shortage of 5.3-liter V8 engines because an unnamed parts supplier has been unable to keep up with demand. This is leading GM to restrict the number of V8 Silverado and Sierra trucks that Chevrolet and GMC dealers are allowed to order.
Although it's unclear how long it will take to resolve the parts shortage, GM doesn't have much time to sort it out, as a new Ford F-150 looms on the horizon. At launch, GM's fullsize trucks were offered only with a base 4.3-liter V6 and the 5.3-liter V8, but a burlier 6.2-liter V8 will be available soon. Interestingly, at least at the moment, GM truck buyers don't seem as willing to downsize to V6 power as buyers of the F-150, which gets some 42-percent of its sales from trucks equipped with its EcoBoost V6 engine (not including the normally aspirated base V6).
Working out the kinks in the Silverado and Sierra's supply chain couldn't be more important to the health of the company. Full-size pickups are a huge profit driver - in 2012, the trucks were said to make up about two-third of GM's total profits.