Dodge 2500 Crew Cab Slt 5.9l Cummins Diesel Silver on 2040-cars

Auto blog

Chrysler investigating complaints of vehicles with faulty power modules

Chrysler owners are hopping mad after experiencing a series of electrical gremlins in some of the company's vehicles. Issues range from mere annoyances - windows rolling down and radios turning off of their own accord - to serious safety issues, with headlights that randomly shut off at night and cars that stall and refuse to start.
The issues are being blamed on the total integrated power module, which can cost up to $1,000 for customers to replace. This, of course, has led to a hefty batch of complaints to the National Highway Traffic Safety Administration, with 240 owners expressing their displeasure so far. Another site, CarComplaints.com, has registered over 300 complaints relating to the 2010 to 2011 Jeep Grand Cherokee and Dodge Durango, alone, according to The New York Times.
Chrysler has acknowledged that it's investigating the complaints and is analyzing the faulty TIPMs, but that isn't quite enough for customers of the affected vehicles. The newspaper has snagged a few of the more harrowing tales with the electrically challenged Chrysler products, culled from the NHTSA complaints.

Chrysler extends fuel tank warranties on LX cars, NHTSA ends probe

The National Highway Traffic Safety Administration has ended its investigation of 153,817, 5.7-liter and 6.1-liter Hemi V8-powered 2006 Chrysler 300, Dodge Charger and Dodge Magnum models after reports of stalling. Chrysler has responded by granting a lifetime warranty on the fuel tanks for these vehicles.
NHTSA received 299 reports of engines stalling while the models were stopped or driving at low speeds, and began an investigation. The government agency found that the control valve shutoff float in the V8s' 19-gallon fuel tank could malfunction if the fuel had too high of an ethanol content. In many cases, the valve would break in the open position, allowing the tank to be overfilled, which would then cause the cars to stall. However, there were no accidents reported, and the vehicles could be restarted immediately.
There will not be a recall on these vehicles because, "the condition represents a low risk to motor vehicle safety and is adequately addressed by Chrysler's extended warranty," NHTSA said to The Detroit News.

Detroit 3 small cars lay an egg in latest Consumer Reports reliability study

Consumer Reports has released its Annual Auto Reliability Survey and the results are, in a word, interesting. While we already covered the score-damaging effects of infotainment systems, there's another big angle to the data that's getting some attention - the utterly dismal scores of the Detroit Three's small car offerings.
The turbocharged Dodge Dart and Chevrolet Cruze, as well as the Ford Fiesta were their respective brands' lowest-scoring models, a stat that's made worse by the fact that the American automakers finished 25th, 21st and 23rd, respectively.
That's not acceptable for The Detroit Free Press' auto critic, Mark Phelan, who has penned a scathing critique of the D3's small car reliability scores, arguing that GM, Ford and Chrysler are "out of excuses."